ILLINOIS POLLUTION CONTROL BOARD
    December 17, 1998
    IN THE MATTER OF:
    WASTEWATER PRETREATMENT
    UPDATE, USEPA REGULATIONS
    (January 1, 1998, through June 30, 1998)
    )
    )
    )
    )
    )
    R99-4
    (Identical-in-Substance Rulemaking -
    Water)
    Proposed Rule. Proposal for Public Comment.
    OPINION AND ORDER OF THE BOARD (by N. J. Melas):
    Pursuant to Sections 7.2 and 13.3 of the Environmental Protection Act (Act) (415 ILCS
    5/7.2 and 13.3 (1996)), the Board proposes amendments to the Illinois wastewater
    pretreatment regulations. As discussed more fully below, the proposed amendments establish
    effluent limitations guidelines and standards under the Federal Water Pollution Control Act
    (FWPCA) for a portion of the pulp, paper, and paperboard industry. The amendments are
    intended to streamline the permit application process to more closely reflect the processes
    found in pulp, paper, and paperboard mills in the United States.
    Section 13.3 of the Act provides for quick adoption of regulations that are identical in
    substance to federal wastewater pretreatment regulations adopted by the United States
    Environmental Protection Agency (USEPA) pursuant to Sections 307(b), (c), and (d) and
    402(b)(9) of the FWPCA (33 U.S.C. §§ 1317(b), (c), (d), 1342(b)(9) (1996)). Section 13.3
    also provides that Title VII of the Act and Section 5 of the Administrative Procedure Act
    (APA) (5 ILCS 100/5-35 and 5-40 (1996)), do not apply to this rulemaking. As such, this
    rulemaking is not subject to first or second-notice review by the Joint Committee on
    Administrative Rules (JCAR). The federal wastewater pretreatment regulations are found at
    40 C.F.R. §§ 400-499, interspersed throughout the federal wastewater effluent discharge rules.
    Section 7.2(b) of the Act (415 ILCS 5/7.2 (1996)) requires the Board to complete its
    identical-in-substance rulemaking actions within one year of the date of the earliest federal
    amendments involved in a docket. In this docket, the sole federal action requiring Board
    action occurred on April 15, 1998. Thus, the Board must complete its rulemaking activity in
    this docket prior to April 15, 1999.
    FEDERAL ACTION CONSIDERED IN THIS RULEMAKING
    This proposed rulemaking incorporates certain federal amendments that occurred during
    the period of January 1, 1998, through June 30, 1998. The USEPA amended its wastewater
    pretreatment regulations once during that period. The single set of federal amendments that
    occurred during that period is as follows:
    Federal Action
    Summary
    2
    April 15, 1998
    (63 Fed. Reg 18503)
    Amendments to the Effluent Limitations
    Guidelines, Pretreatment Standards, and New
    Source Performance Standards: Pulp, Paper,
    and Paperboard Category. The USEPA
    amended its effluent limitations guidelines and
    standards for the
    pulp, paper, and paperboard
    industry
    by reorganizing this section to better
    reflect the processes found in United States
    mills. The amendments also require reduction
    in the discharge of toxic and non-conventional
    chemical compounds found in the effluents
    from mills that fall within the “Bleached
    Papergrade Kraft and Soda” sub-category and
    the “Papergrade Sulfite” sub-category.
    Additionally, the amendments incorporate best
    management practices (BMPs) under the
    FWPCA.
    DISCUSSION
    The USEPA amended its wastewater pretreatment regulations on April 15, 1998.
    Those amendments consolidate into 12 sections what were once 26 sections of effluent
    limitations guidelines and standards for the pulp, paper, and paperboard industry. This
    reorganization also eliminated the separate category of “Builder’s Paper and Roofing Felt” and
    integrates that area into one of the twelve new sub-categories. The USEPA indicated that the
    purpose behind such reorganization was to establish a new scheme that better defines the
    processes typically found in United States mills. Ultimately, the USEPA predicts that these
    changes will result in streamlined regulations that can be implemented more easily by the
    permit applicant.
    The USEPA also revised the existing effluent limitations guidelines and standards for
    the “Bleached Kraft and Soda” sub-category and the “Papergrade Sulfite” sub-category.
    These revisions reduce the permitted discharge level of pollutants into publicly owned
    treatment works by existing and new sources within these two sections. In addition, the
    amendments promulgate BMPs under the FWCPA for a portion of the pulp, paper, and
    paperboard industry. Except for the “Bleached Papergrade Kraft and Soda” section and the
    “Papergrade Sulfite” section, the amendments contain no other substantive changes to the
    limitations and standards applicable to the newly organized sections.
    In this proposal for public comment, the Board incorporates the federal amendments of
    April 15, 1998, both by use of the actual text or through incorporation by reference, with only
    one minor deviation from the federal text. This includes an alteration that the Board finds is
    necessary to adopt the substance of the amended federal requirements into the text of the
    Illinois water pollution control regulations. The Board tabulates below the single deviation
    from the federal text, including a brief description of the revision.
    3
    Deviations from the Text of the Federal Amendments
    Illinois Section
    40 C.F.R. SectionRevision
    307.4011
    40 C.F.R. § 430.110
    Added hyphen to change “nonintegrated” to “non-
    integrated”
    PUBLIC COMMENTS
    The Board will accept public comments in this matter for a period of 45 days after
    publication of the proposed amendments in the
    Illinois Register
    . After the expiration of the
    45-day public comment period, the Board will proceed to adoption of the regulations based on
    this proposal.
    ORDER
    The Board adopts the following proposal for public comment. The Board directs the
    clerk of the Board to cause publication of the following proposal for public comment in the
    Illinois Register
    :
    TITLE 35: ENVIRONMENTAL PROTECTION
    SUBTITLE C: WATER POLLUTION
    CHAPTER I: POLLUTION CONTROL BOARD
    PART 307
    SEWER DISCHARGE CRITERIA
    SUBPART A: GENERAL PROVISIONS
    Section
    307.101
    Preamble (Renumbered)
    307.102
    General Requirements (Renumbered)
    307.103
    Mercury (Renumbered)
    307.104
    Cyanide (STORET number 00720) (Renumbered)
    307.105
    Pretreatment Requirements (Repealed)
    307.1001
    Preamble
    307.1002
    Definitions
    307.1003
    Test Procedures for Measurement
    307.1005
    Toxic Pollutants
    SUBPART B: GENERAL AND SPECIFIC PRETREATMENT REQUIREMENTS
    Section
    307.1101
    General and Specific Requirements
    307.1102
    Mercury
    307.1103
    Cyanide
    4
    SUBPART F: DAIRY PRODUCTS PROCESSING
    Section
    307.1501
    Receiving Stations
    307.1502
    Fluid Products
    307.1503
    Cultured Products
    307.1504
    Butter
    307.1505
    Cottage Cheese and Cultured Cream Cheese
    307.1506
    Natural and Processed Cheese
    307.1507
    Fluid Mix for Ice Cream and other Frozen Desserts
    307.1508
    Ice Cream, Frozen Desserts, Novelties and Other Dairy Desserts
    307.1509
    Condensed Milk
    307.1510
    Dry Milk
    307.1511
    Condensed Whey
    307.1512
    Dry Whey
    SUBPART G: GRAIN MILLS
    Section
    307.1601
    Corn Wet Milling
    307.1602
    Corn Dry Milling
    307.1603
    Normal Wheat Flour Milling
    307.1604
    Bulgur Wheat Flour Milling
    307.1605
    Normal Rice Milling
    307.1606
    Parboiled Rice Milling
    307.1607
    Animal Feed
    307.1608
    Hot Cereal
    307.1609
    Ready-to-eat Cereal
    307.1610
    Wheat Starch and Gluten
    SUBPART H: CANNED AND PRESERVED FRUITS AND VEGETABLES
    Section
    307.1700
    General Provisions
    307.1701
    Apple Juice
    307.1702
    Apple Products
    307.1703
    Citrus Products
    307.1704
    Frozen Potato Products
    307.1705
    Dehydrated Potato Products
    307.1706
    Canned and Preserved Fruits
    307.1707
    Canned and Preserved Vegetables
    307.1708
    Canned and Miscellaneous Specialties
    SUBPART I: CANNED AND PRESERVED SEAFOOD
    Section
    307.1801
    Farm-raised Catfish
    307.1815
    Fish Meal Processing Sub-category
    5
    SUBPART J: SUGAR PROCESSING
    Section
    307.1901
    Beet Sugar Processing
    307.1902
    Crystalline Cane Sugar Refining
    307.1903
    Liquid Cane Sugar Refining
    SUBPART K: TEXTILE MILLS
    Section
    307.2000
    General Provisions
    307.2001
    Wool Scouring
    307.2002
    Wool Finishing
    307.2003
    Low Water Use Processing
    307.2004
    Woven Fabric Finishing
    307.2005
    Knit Fabric Finishing
    307.2006
    Carpet Finishing
    307.2007
    Stock and Yarn Finishing
    307.2008
    Nonwoven Manufacturing
    307.2009
    Felted Fabric Processing
    SUBPART L: CEMENT MANUFACTURING
    Section
    307.2101
    Nonleaching
    307.2102
    Leaching
    307.2103
    Materials Storage Piles Runoff
    SUBPART M: FEEDLOTS
    Section
    307.2201
    General
    307.2202
    Ducks
    SUBPART N: ELECTROPLATING
    Section
    307.2300
    General Provisions
    307.2301
    Electroplating of Common Metals
    307.2302
    Electroplating of Precious Metals
    307.2304
    Anodizing
    307.2305
    Coatings
    307.2306
    Chemical Etching and Milling
    307.2307
    Electroless Plating
    307.2308
    Printed Circuit Boards
    SUBPART O: ORGANIC CHEMICALS, PLASTICS AND SYNTHETIC FIBERS
    Section
    307.2400
    General Provisions
    307.2401
    Rayon Fibers
    6
    307.2402
    Other Fibers
    307.2403
    Thermoplastic Resins
    307.2404
    Thermosetting Resins
    307.2405
    Commodity Organic Chemicals
    307.2406
    Bulk Organic Chemicals
    307.2407
    Specialty Organic Chemicals
    307.2410
    Indirect Discharge Point Sources
    307.2490
    Non-complexed Metal-bearing and Cyanide-bearing Wastestreams
    307.2491
    Complexed Metal-bearing Wastestreams
    SUBPART P: INORGANIC CHEMICALS MANUFACTURING
    Section
    307.2500
    General Provisions
    307.2501
    Aluminum Chloride Production
    307.2502
    Aluminum Sulfate Production
    307.2503
    Calcium Carbide Production
    307.2504
    Calcium Chloride Production
    307.2505
    Calcium Oxide Production
    307.2506
    Chlor-alkali Process (Chlorine and Sodium or Potassium Hydroxide
    Production)
    307.2508
    Hydrofluoric Acid Production
    307.2509
    Hydrogen Peroxide Production
    307.2511
    Potassium Metal Production
    307.2512
    Potassium Dichromate Production
    307.2513
    Potassium Sulfate Production
    307.2514
    Sodium Bicarbonate Production
    307.2516
    Sodium Chloride Production
    307.2517
    Sodium Dichromate and Sodium Sulfate Production
    307.2520
    Sodium Sulfite Production
    307.2522
    Titanium Dioxide Production
    307.2523
    Aluminum Fluoride Production
    307.2524
    Ammonium Chloride Production
    307.2527
    Borax Production
    307.2528
    Boric Acid Production
    307.2529
    Bromine Production
    307.2530
    Calcium Carbonate Production
    307.2531
    Calcium Hydroxide Production
    307.2533
    Carbon Monoxide and Byproduct Hydrogen Production
    307.2534
    Chrome Pigments Production
    307.2535
    Chromic Acid Production
    307.2536
    Copper Salts Production
    307.2538
    Ferric Chloride Production
    307.2540
    Fluorine Production
    307.2541
    Hydrogen Production
    307.2542
    Hydrogen Cyanide Production
    7
    307.2543
    Iodine Production
    307.2544
    Lead Monoxide Production
    307.2545
    Lithium Carbonate Production
    307.2547
    Nickel Salts Production
    307.2549
    Oxygen and Nitrogen Production
    307.2550
    Potassium Chloride Production
    307.2551
    Potassium Iodide Production
    307.2553
    Silver Nitrate Production
    307.2554
    Sodium Bisulfite Production
    307.2555
    Sodium Fluoride Production
    307.2560
    Stannic Oxide Production
    307.2563
    Zinc Sulfate Production
    307.2564
    Cadmium Pigments and Salts Production
    307.2565
    Cobalt Salts Production
    307.2566
    Sodium Chlorate Production
    307.2567
    Zinc Chloride Production
    SUBPART R: SOAP AND DETERGENTS
    Section
    307.2701
    Soap Manufacturing by Batch Kettle
    307.2702
    Fatty Acid Manufacturing by Fat Splitting
    307.2703
    Soap Manufacturing by Fatty Acid Neutralization
    307.2704
    Glycerine Concentration
    307.2705
    Glycerine Distillation
    307.2706
    Manufacture of Soap Flakes and Powders
    307.2707
    Manufacture of Bar Soaps
    307.2708
    Manufacture of Liquid Soaps
    307.2709
    Oleum Sulfonation and Sulfation
    307.2710
    Air-Sulfur Trioxide Sulfation and Sulfonation
    307.2711
    Sulfur Trioxide Solvent and Vacuum Sulfonation
    307.2712
    Sulfamic Acid Sulfation
    307.2713
    Chlorosulfonic Acid Sulfation
    307.2714
    Neutralization of Sulfuric Acid Esters and Sulfonic Acids
    307.2715
    Manufacture of Spray Dried Detergents
    307.2716
    Manufacture of Liquid Detergents
    307.2717
    Manufacturing of Detergents by Dry Blending
    307.2718
    Manufacture of Drum Dried Detergents
    307.2719
    Manufacture of Detergent Bars and Cakes
    SUBPART S: FERTILIZER MANUFACTURING
    Section
    307.2801
    Phosphate
    307.2802
    Ammonia
    307.2803
    Urea
    307.2804
    Ammonium Nitrate
    8
    307.2805
    Nitric Acid
    307.2806
    Ammonium Sulfate Production
    307.2807
    Mixed and Blend Fertilizer Production
    SUBPART T: PETROLEUM REFINING
    Section
    307.2901
    Topping
    307.2902
    Cracking
    307.2903
    Petrochemical
    307.2904
    Lube
    307.2905
    Integrated
    SUBPART U: IRON AND STEEL MANUFACTURING
    Section
    307.3000
    General Provisions
    307.3001
    Cokemaking
    307.3002
    Sintering
    307.3003
    Ironmaking
    307.3004
    Steelmaking
    307.3005
    Vacuum Degassing
    307.3006
    Continuous Casting
    307.3007
    Hot Forming
    307.3008
    Salt Bath Descaling
    307.3009
    Acid Pickling
    307.3010
    Cold Forming
    307.3011
    Alkaline Cleaning
    307.3012
    Hot Coating
    SUBPART V: NONFERROUS METALS MANUFACTURING
    Section
    307.3100
    General Provisions
    307.3101
    Bauxite Refining
    307.3102
    Primary Aluminum Smelting
    307.3103
    Secondary Aluminum Smelting
    307.3104
    Primary Copper Smelting
    307.3105
    Primary Electrolytic Copper Refining
    307.3106
    Secondary Copper
    307.3107
    Primary Lead
    307.3108
    Primary Zinc
    307.3109
    Metallurgical Acid Plants
    307.3110
    Primary Tungsten
    307.3111
    Primary Columbium-Tantalum
    307.3112
    Secondary Silver
    307.3113
    Secondary Lead
    307.3114
    Primary Antimony
    9
    307.3115
    Primary Beryllium
    307.3116
    Primary and Secondary Germanium and Gallium
    307.3117
    Secondary Indium
    307.3118
    Secondary Mercury
    307.3119
    Primary Molybdenum and Rhenium
    307.3120
    Secondary Molybdenum and Vanadium
    307.3121
    Primary Nickel and Cobalt
    307.3122
    Secondary Nickel
    307.3123
    Primary Precious Metals and Mercury
    307.3124
    Secondary Precious Metals
    307.3125
    Primary Rare Earth Metals
    307.3126
    Secondary Tantalum
    307.3127
    Secondary Tin
    307.3128
    Primary and Secondary Titanium
    307.3129
    Secondary Tungsten and Cobalt
    307.3130
    Secondary Uranium
    307.3131
    Primary Zirconium and Hafnium
    SUBPART X: STEAM ELECTRIC POWER GENERATING
    Section
    307.3301
    Steam Electric Power Generating
    SUBPART Y: FERROALLOY MANUFACTURING
    Section
    307.3401
    Open Electric Furnaces With Wet Air Pollution Control Devices
    307.3402
    Covered Electric Furnaces and Other Smelting Operations with Wet Air
    Pollution Control Devices
    307.3403
    Slag Processing
    307.3404
    Covered Calcium Carbide Furnaces With Wet Air Pollution Control
    Devices
    307.3405
    Other Calcium Carbide Furnaces
    307.3406
    Electrolytic Manganese Products
    307.3407
    Electrolytic Chromium
    SUBPART Z: LEATHER TANNING AND FINISHING
    Section
    307.3500
    General Provisions
    307.3501
    Hair Pulp, Chrome Tan, Retan-Wet Finish
    307.3502
    Hair Save, Chrome Tan, Retan-Wet Finish
    307.3503
    Hair Save or Pulp, Non-Chrome Tan, Retan-Wet Finish
    307.3504
    Retan-Wet Finish-Sides
    307.3505
    No Beamhouse
    307.3506
    Through-the-Blue
    307.3507
    Shearling
    307.3508
    Pigskin
    10
    307.3509
    Retan-Wet Finish-Splits
    307.3590
    Potassium Ferricyanide Titration Method
    SUBPART BA: GLASS MANUFACTURING
    Section
    307.3601
    Insulation Fiberglass
    307.3602
    Sheet Glass Manufacturing
    307.3603
    Rolled Glass Manufacturing
    307.3604
    Plate Glass Manufacturing
    307.3605
    Float Glass Manufacturing
    307.3606
    Automotive Glass Tempering
    307.3607
    Automotive Glass Laminating
    307.3608
    Glass Container Manufacturing
    307.3610
    Glass Tubing (Danner) Manufacturing
    307.3611
    Television Picture Tube Envelope Manufacturing
    307.3612
    Incandescent Lamp Envelope Manufacturing
    307.3613
    Hand Pressed and Blown Glass Manufacturing
    SUBPART BB: ASBESTOS MANUFACTURING
    Section
    307.3701
    Asbestos-Cement Pipe
    307.3702
    Asbestos-Cement Sheet
    307.3703
    Asbestos Paper (Starch Binder)
    307.3704
    Asbestos Paper (Elastomeric Binder)
    307.3705
    Asbestos Millboard
    307.3706
    Asbestos Roofing
    307.3707
    Asbestos Floor Tile
    307.3708
    Coating or Finishing of Asbestos Textiles
    307.3709
    Solvent Recovery
    307.3710
    Vapor Absorption
    307.3711
    Wet Dust Collection
    SUBPART BC: RUBBER MANUFACTURING
    Section
    307.3801
    Tire and Inner Tube Plants
    307.3802
    Emulsion Crumb Rubber
    307.3803
    Solution Crumb Rubber
    307.3804
    Latex Rubber
    307.3805
    Small-Sized General Molded, Extruded and Fabricated Rubber Plants
    307.3806
    Medium-Sized General Molded, Extruded and Fabricated Rubber Plants
    307.3807
    Large-Sized General Molded, Extruded and Fabricated Rubber Plants
    307.3808
    Wet Digestion Reclaimed Rubber
    307.3809
    Pan, Dry Digestion and Mechanical Reclaimed Rubber
    307.3810
    Latex-Dipped, Latex-Extruded and Latex-Molded Rubber
    307.3811
    Latex Foam
    11
    SUBPART BD: TIMBER PRODUCTS PROCESSING
    Section
    307.3900
    General Provisions
    307.3901
    Barking
    307.3902
    Veneer
    307.3903
    Plywood
    307.3904
    Dry Process Hardboard
    307.3905
    Wet Process Hardboard
    307.3906
    Wood Preserving-Water Borne or Nonpressure
    307.3907
    Wood Preserving-Steam
    307.3908
    Wood Preserving-Boulton
    307.3909
    Wet Storage
    307.3910
    Log Washing
    307.3911
    Sawmills and Planing Mills
    307.3912
    Finishing
    307.3913
    Particleboard Manufacturing
    307.3914
    Insulation Board
    307.3915
    Wood Furniture and Fixture Production Without Water Wash Spray
    Booth(s) or Without Laundry Facilities
    307.3916
    Wood Furniture and Fixture Production with Water Wash Spray Booth(s)
    or With Laundry Facilities
    SUBPART BE: PULP, PAPER AND PAPERBOARD
    Section
    307.4000
    General Provisions
    307.4001
    Dissolving KraftUnbleached Kraft
    307.4002
    Bleached Papergrade Kraft and SodaSemi-Chemical
    307.4003
    Unbleached Kraft
    307.4004
    Dissolving SulfiteUnbleached Kraft-Neutral Sulfite Semi-Chemical (Cross
    Recovery)
    307.4005
    Papergrade SulfitePaperboard From Wastepaper
    307.4006
    Semi-ChemicalDissolving Kraft
    307.4007
    Mechanical PulpMarket Bleached Kraft
    307.4008
    Non-Wood Chemical PulpBCT Bleached Kraft
    307.4009
    Secondary Fiber DeinkFine Bleached Kraft
    307.4010
    Secondary Fiber Non-DeinkPapergrade Sulfite (Blow Pit Wash)
    307.4011
    Fine and Lightweight Papers from Purchased PulpDissolving Sulfite Pulp
    307.4012
    Tissue, Filter, Non-Woven, and Paperboard from Purchased
    PulpGroundwood-Chemi-Mechanical
    307.4013
    Groundwood-Thermo-Mechanical (Repealed)
    307.4014
    Groundwood-CMN Papers (Repealed)
    307.4015
    Groundwood-Fine Papers (Repealed)
    307.4016
    Soda (Repealed)
    307.4017
    Deink (Repealed)
    12
    307.4018
    Nonintegrated-Fine Papers (Repealed)
    307.4019
    Nonintegrated-Tissue Papers (Repealed)
    307.4020
    Tissue From Wastepaper (Repealed)
    307.4021
    Papergrade Sulfite (Drum Wash) (Repealed)
    307.4022
    Unbleached Kraft and Semi-Chemical (Repealed)
    307.4023
    Wastepaper-Molded Products (Repealed)
    307.4024
    Nonintegrated-Lightweight Papers (Repealed)
    307.4025
    Nonintegrated-Filter and Nonwoven Papers (Repealed)
    307.4026
    Nonintegrated-Paperboard (Repealed)
    SUBPART BF: BUILDERS' PAPER AND BOARD MILLS (Repealed)
    Section
    307.4101
    Builder's Paper and Roofing Felt (Repealed)
    SUBPART BG: MEAT PRODUCTS
    Section
    307.4201
    Simple Slaughterhouse
    307.4202
    Complex Slaughterhouse
    307.4203
    Low-Processing Packinghouse
    307.4204
    High-Processing Packinghouse
    307.4205
    Small Processor
    307.4206
    Meat Cutter
    307.4207
    Sausage and Luncheon Meats Processor
    307.4208
    Ham Processor
    307.4209
    Canned Meats Processor
    307.4210
    Renderer
    SUBPART BH: METAL FINISHING
    Section
    307.4300
    General Provisions
    307.4301
    Metal Finishing
    SUBPART BN: PHARMACEUTICAL MANUFACTURING
    Section
    307.4900
    General Provisions
    307.4901
    Fermentation Products
    307.4902
    Extraction Products
    307.4903
    Chemical Synthesis Products
    307.4904
    Mixing/Compounding and Formulation
    307.4905
    Research
    SUBPART BR: PAVING AND ROOFING MATERIALS (TARS AND ASPHALT)
    Section
    307.5301
    Asphalt Emulsion
    307.5302
    Asphalt Concrete
    13
    307.5303
    Asphalt Roofing
    307.5304
    Linoleum and Printed Asphalt Felt
    SUBPART BU: PAINT FORMULATING
    Section
    307.5601
    Oil-Base Solvent Wash Paint
    SUBPART BV: INK FORMULATING
    Section
    307.5701
    Oil-Base Solvent Wash Ink
    SUBPART CD: PESTICIDE CHEMICALS
    Section
    307.6500
    General Provisions
    307.6501
    Organic Pesticide Chemicals Manufacturing
    307.6502
    Metallo-Organic Pesticides Chemicals Manufacturing
    307.6503
    Pesticide Chemicals Formulating and Packaging
    SUBPART CG: CARBON BLACK MANUFACTURING
    Section
    307.6801
    Carbon Black Furnace Process
    307.6802
    Carbon Black Thermal Process
    307.6803
    Carbon Black Channel Process
    307.6804
    Carbon Black Lamp Process
    SUBPART CJ: BATTERY MANUFACTURING
    Section
    307.7100
    General Provisions
    307.7101
    Cadmium
    307.7102
    Calcium
    307.7103
    Lead
    307.7104
    Leclanche
    307.7105
    Lithium
    307.7106
    Magnesium
    307.7107
    Zinc
    SUBPART CL: PLASTICS MOLDING AND FORMING
    Section
    307.7300
    General Provisions
    307.7301
    Contact Cooling and Heating Water
    307.7302
    Cleaning Water
    307.7303
    Finishing Water
    SUBPART CM: METAL MOLDING AND CASTING
    14
    Section
    307.7400
    General Provisions
    307.7401
    Aluminum Casting
    307.7402
    Copper Casting
    307.7403
    Ferrous Casting
    307.7404
    Zinc Casting
    SUBPART CN: COIL COATING
    Section
    307.7500
    General Provisions
    307.7501
    Steel Basis Material
    307.7502
    Galvanized Basis Material
    307.7503
    Aluminum Basis Material
    307.7504
    Canmaking
    SUBPART CO: PORCELAIN ENAMELING
    Section
    307.7600
    General Provisions
    307.7601
    Steel Basis Material
    307.7602
    Cast Iron Basis Material
    307.7603
    Aluminum Basis Material
    307.7604
    Copper Basis Material
    SUBPART CP: ALUMINUM FORMING
    Section
    307.7700
    General Provisions
    307.7701
    Rolling With Neat Oils
    307.7702
    Rolling With Emulsions
    307.7703
    Extrusion
    307.7704
    Forging
    307.7705
    Drawing With Neat Oils
    307.7706
    Drawing With Emulsions or Soaps
    SUBPART CQ: COPPER FORMING
    Section
    307.7800
    General Provisions
    307.7801
    Copper Forming
    307.7802
    Beryllium Copper Forming
    SUBPART CR: ELECTRICAL AND ELECTRONIC COMPONENTS
    Section
    307.7901
    Semiconductor
    307.7902
    Electronic Crystals
    307.7903
    Cathode Ray Tube
    307.7904
    Luminescent Materials
    15
    SUBPART CT: NONFERROUS METALS FORMING AND METAL POWDERS
    Section
    307.8100
    General Provisions
    307.8101
    Lead-Tin-Bismuth Forming
    307.8102
    Magnesium Forming
    307.8103
    Nickel-Cobalt Forming
    307.8104
    Precious Metals Forming
    307.8105
    Refractory Metals Forming
    307.8106
    Titanium Forming
    307.8107
    Uranium Forming
    307.8108
    Zinc Forming
    307.8109
    Zirconium-Hafnium Forming
    307.8110
    Metal Powders
    Appendix A
    References to Previous Rules (Repealed)
    AUTHORITY: Implementing Sections 13 and 13.3 and authorized by Section 27 of the
    Environmental Protection Act [415 ILCS 5/13, 13.3, and 27].
    SOURCE: Adopted in R70-5, at 1 PCB 426, March 31, 1971; amended in R71-14, at 4 PCB 3,
    March 7, 1972; amended in R74-3, at 19 PCB 182, October 30, 1975; amended in R74-15, 16, at
    31 PCB 405, at 2 Ill. Reg. 44, p. 151, effective November 2, 1978; amended in R76-17, at 31
    PCB 713, at 2 Ill. Reg. 45, p. 101, effective November 5, 1978; amended in R76-21, at 44 PCB
    203, at 6 Ill. Reg. 563, effective December 24, 1981; codified at 6 Ill. Reg. 7818; amended in
    R82-5, 10, at 54 PCB 411, at 8 Ill. Reg. 1625, effective January 18, 1984; amended in R86-44 at
    12 Ill. Reg. 2592, effective January 13, 1988; amended in R88-11 at 12 Ill. Reg. 13094, effective
    July 29, 1988; amended in R88-18 at 13 Ill. Reg. 1794, effective January 31, 1989; amended in
    R89-3 at 13 Ill. Reg. 19288, effective November 17, 1989; amended in R88-9 at 14 Ill. Reg.
    3100, effective February 20, 1990; amended in R89-12 at 14 Ill. Reg. 7620, effective May 8,
    1990; amended in R91-5 at 16 Ill. Reg. 7377, effective April 27, 1992; amended in R93-2 at 17
    Ill. Reg. 19483, effective October 29, 1993; amended in R94-10 at 19 Ill. Reg. 9142, effective
    June 23, 1995; amended in R95-22 at 20 Ill. Reg 5549, effective April 1, 1996; amended in R97-
    23 at 21 Ill. Reg. 11930, effective August 12, 1997; amended in R99-4 at 23 Ill. Reg. ,
    effective .
    SUBPART BE: PULP, PAPER AND PAPERBOARD
    Section 307.4000 General Provisions
    a)
    Applicability. This Subpart applies to any pulp, paper or paperboard mill which
    introduces or may introduce process wastewater pollutants into a POTW.
    16
    b)
    General definitions. The Board incorporates by reference 40 CFR 430.01
    (199886). This incorporation includes no later amendments or editions.
     
    c)
    Best Management Practices. The Board incorporates by reference 40 CFR 430.03
    (1998). This incorporation includes no later amendments or editions.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4001 Dissolving KraftUnbleached Kraft
    a)
    Applicability. This Section applies to discharges resulting from the production of
    dissolving pulp at kraft millspulp and paper at unbleached kraft mills.
     
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.11
    (199886). This incorporation includes no later amendments or editions.
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.16 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    1)
    The Board incorporates by reference 40 CFR 430.17 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4002 Bleached Papergrade Kraft and SodaSemi-Chemical
    a)
    Applicability. This Section applies to discharges resulting from: the production of
    market pulp at bleached kraft mills; the integrated production of paperboard,
    coarse paper, and tissue paper at bleached kraft mills; the integrated production of
    pulp and fine papers at bleached kraft mills; and the integrated production of pulp
    17
    and paper at soda mills the integrated production of pulp and paper at semi-
    chemical mills.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.21
    (199886). This incorporation includes no later amendments or editions.
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.26 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    1)
    The Board incorporates by reference 40 CFR 430.27 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation
    the construction of which commenced after January 6, 1981.
    e) Best Management Practices. The Board incorporates by reference 40 CFR 430.28
    (1998). This incorporation includes no later amendments or editions.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4003 Unbleached Kraft
    a) Applicability. This Section applies to discharges resulting from: the production of
    pulp and paper at unbleached kraft mills; the production of pulp and paper at
    unbleached kraft-neutral sulfite semi-chemical (cross recovery) mills; and the
    production of pulp and paper at combined unbleached kraft and semi-chemical
    mills, wherein the spent semi-chemical cooking liquor is burned within the
    unbleached kraft chemical recovery system.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.31
    (1998). This incorporation includes no later amendments or editions.
    c) Existing sources:
    18
    1) The Board incorporates by reference 40 CFR 430.36 (1998). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.37 (1998). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Added at 23 Ill. Reg. , effective )
    Section 307.4004 Dissolving Sulfite Unbleached Kraft-Neutral Sulfite Semi-Chemical (Cross
    Recovery)
    a)
    Applicability. This Section applies to discharges resulting from the production of
    pulp at dissolving sulfite mills and paper at unbleached kraft-neutral sulfite semi-
    chemical (cross recovery) mills.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.41
    (199887). This incorporation includes no later amendments or editions.
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.46 (199887). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (c)(1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    19
    1)
    The Board incorporates by reference 40 CFR 430.47 (199887). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (d)(1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4005 Papergrade SulfitePaperboard From Wastepaper
    a)
    Applicability. This Section applies to discharges resulting from the: integrated
    production of pulp and paper at papergrade sulfite mills, where blow pit pulp
    washing techniques are used; and the integrated production of pulp and paper at
    papergrade sulfite mills where vacuum or pressure drums are used to wash pulp
    production of paperboard from wastepaper.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.51
    (199886). This incorporation includes no later amendments or editions.
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.56 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    1)
    The Board incorporates by reference 40 CFR 430.57 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Amended at 23 Ill. Reg. , effective )
    20
    Section 307.4006 Semi-ChemicalDissolving Kraft
    a)
    Applicability. This Section applies to discharges resulting from the integrated
    production of pulp and paper at semi-chemical millsproduction of dissolving pulp
    at kraft mills.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.61
    (199886). This incorporation includes no later amendments or editions.
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.66 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    1)
    The Board incorporates by reference 40 CFR 430.67 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4007 Mechanical Pulp Market Bleached Kraft
    a)
    Applicability. This Section applies to discharges resulting from: the production of
    pulp and paper at groundwood chemi-mechanical mills; the production of pulp and
    paper at groundwood mills through the application of the thermo-mechanical
    process; the integrated production of pulp and coarse paper, molded pulp
    products, and newsprint at groundwood mills; and the integrated production of
    pulp and fine paper at groundwood mills the production of market pulp at bleached
    kraft mills.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.71
    (199886). This incorporation includes no later amendments or editions.
    21
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.76 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    1)
    The Board incorporates by reference 40 CFR 430.77 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4008 Non-Wood Chemical PulpBCT Bleached Kraft
    a)
    Applicability. This Section applies to discharges resulting from the production of
    pulp and paper at non-wood chemical pulp mills. This sub-category includes, but
    is not limited to, mills producing non-wood pulps from chemical pulping processes
    such as kraft, sulfite, or sodaintegrated production of paperboard, coarse paper or
    tissue paper at bleached kraft mills.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.81
    (199886). This incorporation includes no later amendments or editions.
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.86 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    22
    1)
    The Board incorporates by reference 40 CFR 430.87 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4009 Secondary Fiber DeinkFine Bleached Kraft
    a)
    Applicability. This Section applies to discharges resulting from the integrated
    production of pulp and paper at deink mills or fine papers at bleached kraft mills.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.91
    (199886). This incorporation includes no later amendments or editions.
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.96 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    1)
    The Board incorporates by reference 40 CFR 430.97 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Amended at 23 Ill. Reg. , effective )
    23
    Section 307.4010 Secondary Fiber Non-Deink Papergrade Sulfite (Blow Pit Wash)
    a)
    Applicability. This Section applies to discharges resulting from the production of:
    paperboard from wastepaper; tissue paper from wastepaper without deinking at
    secondary fiber mills; molded products from wastepaper without deinking at
    secondary fiber mills; and builders’ paper and roofing felt from wastepaper
    integrated production of pulp and paper at papergrade sulfite mills, where blow pit
    pulp washing techniques are used.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.101
    (199886). This incorporation includes no later amendments or editions.
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.106 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    1)
    The Board incorporates by reference 40 CFR 430.107 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4011
    Fine and Lightweight Papers from Purchased Pulp Dissolving Sulfite
    Pulp
    a)
    Applicability. This Section applies to discharges resulting from the production of:
    fine paper at non-integrated mills; and lightweight paper at non-integrated mills
    pulp at dissolving sulfite mills.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.111
    (199886). This incorporation includes no later amendments or editions.
    24
    c)
    Existing sources:
    1)
    The Board incorporates by reference 40 CFR 430.116 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d)
    New sources:
    1)
    The Board incorporates by reference 40 CFR 430.117 (199886). This
    incorporation includes no later amendments or editions.
    2)
    No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3)
    "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4012
    Tissue, Filter, Non-Woven, and Paperboard From Purchased Pulp
    Groundwood-Chemi-Mechanical
    a)
    Applicability. This Section applies to discharges resulting from the production of
    tissue papers at non-integrated mills, filter and non-woven papers at non-integrated
    mills, and paperboard at non-integrated mills. The production of electrical grades
    of board and matrix board is not included in this subpart pulp and paper at
    groundwood chemi-mechanical mills.
    b)
    Specialized definitions. The Board incorporates by reference 40 CFR 430.121
    (199886). This incorporation includes no later amendments or editions.
    c)
    Existing sources: These sources shall comply with the general and specific
    pretreatment requirements of Subpart B.
    d)
    New sources: All sources are regulated as existing sources.
    (Source: Amended at 23 Ill. Reg. , effective )
    Section 307.4013 Groundwood-Thermo-Mechanical (Repealed)
    25
    a) Applicability. This Section applies to discharges resulting from the production of
    pulp and paper at groundwood mills through the application of the thermo-
    mechanical process.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.131
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.136 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.137 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4014 Groundwood-CMN Papers (Repealed)
    a) Applicability. This Section applies to discharges resulting from the integrated
    production of pulp and coarse paper, molded pulp products and newsprint at
    groundwood mills.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.141
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.146 (1986). This
    incorporation includes no later amendments or editions.
    26
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.147 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4015 Groundwood-Fine Papers (Repealed)
    a) Applicability. This Section applies to discharges resulting from the integrated
    production of pulp and fine paper at groundwood mills.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.151
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.156 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.157 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    27
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4016 Soda (Repealed)
    a) Applicability. This Section applies to discharges resulting from the integrated
    production of pulp and paper at soda mills.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.161
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.166 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.167 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4017 Deink (Repealed)
    a) Applicability. This Section applies to discharges resulting from the integrated
    production of pulp and paper at deink mills.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.171
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    28
    1) The Board incorporates by reference 40 CFR 430.176 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.177 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4018 Nonintegrated-Fine Papers (Repealed)
    a) Applicability. This Section applies to discharges resulting from the production of
    fine paper at nonintegrated mills.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.181
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.186 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.187 (1986). This
    incorporation includes no later amendments or editions.
    29
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4019 Nonintergrated-Tissue Papers (Repealed)
    a) Applicability. This Section applies to discharges resulting from the production of
    tissue papers at non-integrated mills.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.191
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.196 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.197 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4020 Tissue From Wastepaper (Repealed)
    a) Applicability. This Section applies to discharges resulting from the production of
    tissue paper from wastepaper without deinking at secondary fiber mills.
    30
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.201
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.206 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.207 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4021 Papergrade Sulfite (Drum Wash) (Repealed)
    a) Applicability. This Section applies to discharges resulting from the integrated
    production of pulp and paper at papergrade sulfite mills, where vacuum or
    pressure drums are used to wash pulp.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.211
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.216 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    31
    1) The Board incorporates by reference 40 CFR 430.217 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4022 Unbleached Kraft and Semi-Chemical (Repealed)
    a) Applicability. This Section applies to discharges resulting from the production of
    pulp and paper at combined unbleached kraft and semi-chemical mills, in which the
    spent semi-chemical cooking liquor is burned within the unbleached kraft chemical
    recovery system.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.221
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.226 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.227 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    32
    Section 307.4023 Wastepaper-Molded Products (Repealed)
    a) Applicability. This Section applies to discharges resulting from the production of
    molded products from wastepaper without deinking at secondary fiber mills.
     
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.231
    (1986).This incorporation includes no later amendments or editions.
     
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.236 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.237 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4024 Nonintegrated-Lightweight Papers (Repealed)
    a) Applicability. This Section applies to discharges resulting from the production of
    lightweight paper at nonintegrated mills.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.241
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.246 (1986). This
    incorporation includes no later amendments or editions.
    33
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.247 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4025 Nonintegrated-Filter and Nonwoven Papers (Repealed)
    a) Applicability. This Section applies to discharges resulting from the production of
    filter and nonwoven papers at nonintegrated mills.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.251
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.256 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.257 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    34
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    Section 307.4026 Nonintegrated-Paperboard (Repealed)
    a) Applicability. This Section applies to discharges resulting from the production of
    paperboard at nonintegrated mills. The production of electrical grades of board
    and matrix board is not included in this Section.
    b) Specialized definitions. The Board incorporates by reference 40 CFR 430.261
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 430.266 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 430.267 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    SUBPART BF: BUILDERS' PAPER AND BOARD MILLS (Repealed)
    Section 307.4101 Builder's Paper and Roofing Felt (Repealed)
    a) Applicability. This Section applies to discharges resulting from the production of
    builders' paper and roofing felt from wastepaper.
    35
    b) Specialized definitions. The Board incorporates by reference 40 CFR 431.11
    (1986). This incorporation includes no later amendments or editions.
    c) Existing sources:
    1) The Board incorporates by reference 40 CFR 431.16 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    d) New sources:
    1) The Board incorporates by reference 40 CFR 431.17 (1986). This
    incorporation includes no later amendments or editions.
    2) No person subject to the pretreatment standards incorporated by reference
    in subsection (1) shall cause, threaten or allow the discharge of any
    contaminant to a POTW in violation of such standards.
    3) "New source" means any building, structure, facility or installation the
    construction of which commenced after January 6, 1981.
    (Source: Repealed at 23 Ill. Reg. , effective )
    IT IS SO ORDERED.
    I, Dorothy M. Gunn, Clerk of the Illinois Pollution Control Board, hereby certify that
    the above order was adopted on the 17th day of December 1998 by a vote of 6-0.
    Dorothy M. Gunn, Clerk
    Illinois Pollution Control Board

    Back to top