REC~VED
CLERK~SOFFICE
BEFORE THE ILLINOIS POLLUTION CONTROL BOARI9ECSTATE
OF
1
ILLINOIS.
7 2003
ARCLAR COMPAI’TY, LLC
)
Pollution Control Board
Coal Preparation Facility
—
Willow Lake
)
(
)
PROPERTY IDENTIFICATION NUMBER
)
PCB 0?-
09-01-300-001-0080
)
(Tax Certification)
)
)
NOTICE
TO:
Dorothy Gunn, Clerk
Donald Coovert
Illinois Pollution Control Board
5949
Beau Jardine Drive
State ofIllinois Center
Indianapolis, Indiana 46237
100W. Randolph Street, Suite 11-500
Chicago, Illinois 60601
Steve Santarelli
Illinois Department ofRevenue
- -
101 West Jefferson
P.O. Box 19033
Springfield, Illinois 62794
PLEASE TAKE NOTICE that I have today filed with the Office ofthe Pollution Control
Board the APPEARANCE AND RECOMMENDATION of the Illinois Environmental
Protection Agency,
a
copy ofwhich is herewith served upon you.
By:
~7~co
Robb H. Layman
Special Assistant Attorney General
ARDC
#6205498
Date: December 16, 2003
ILLINOIS ENVIRONMENTAL PROTECTION AGENCY
1021 North Grand Avenue East
P.O. Box 19276
Springfield, IL 62794-9276
Telephone: 217/782-5544
Facsimile: 217/782-9807
THIS FILING IS SUBMITTED ON RECYCLED PAPER
CLFRK~SCE
~OFFICEV ED
DEC 17 2003
BEFORE THE ILLINOIS POLLUTION CONTROL BOA~l~rEOF ILLINOIS
Pollution Control Board
ARCLAR COMPANY, LLC
)
Coal Preparation Facility
—
Willow Lake
)
(
)
PRORERTY IDENTIFICATION NUMBER
)
PCB ø3~-
09-0l~3p0-001-0080
)
(Tax Certification)
)
)
APPEARANCE
I hereby file my Appearance in this proceeding on behalf of the Illinois Environmental
Protection Agency.
By:
________________
Robb H. Layman
Special Assistant Attorney General
ARDC #6205498
DATED: December 16, 2003
ILLINOIS ENVIRONMENTAL PROTECTION AGENCY
1021 North Grand Avenue East
P.O.
Box 19276
Springfield, Illinois 62794-9276
Telephone: 217/782-5544
Facsimile: 217/782-9807
THIS FILING IS SUBMITTED ON RECYCLED PAPER
RECEIVED
CLERK’S OFFICE
DEC 17 2003
BEFORE THE ILLINOIS POLLUTION CONTROL BOARI~1ATE
Pollution
OF
Control
ILLINOIS
Board
ARCLAR COMPANY, LLC
)
Coal Preparation Facility
—
Willow Lake
)
(
)
PROPERTY IDENTIFICATION NUMBER
)
PCB ø~
09~01L3.00~001~0080
)
(Tax Certification)
)
)
RECOMMENDATION
NOW COMES the ILLINOIS ENVIRONMENTAL PROTECTION AGENCY (“Illinois
EPA”), through its attorneys, and pursuant to 35 Iii. Adm. Code 125.204 ofthe ILLINOIS
POLUTION CONTROL BOARD’S (“Board”) regulations, files the Illinois EPA’s
Recommendation in the above-referenced tax certification request of air pollution control
facilities. In support thereof, the Illinois EPA states as follows:
1.
On October 16, 2003, the Illinois EPA received a request and supporting
-
information from ARCLAR COMPANY, LLC (“Arclar”) concerning the proposed tax
certification ofair pollution control facilities for certain sources and/or equipment located at its
Willow Lake facility. A copy of the relevantportions ofthe application is attached hereto.
Exhibit A.
2.
Additional information concerning the property identification numbers was faxed
to the Illinois EPA on November 13, 2003. Exhibit B.
3.
The applicant’s address is as follows:
Arclar Company, LLC
Attention: Mr. Donald Coovert
5949 Beau Jardine Drive
Indianapolis, Indiana 46237
4.
The air pollution control facilities involved in this request are located at 420 Long
Lane Road, Equality, Saline County, Illinois 62934 and consist ofthe following:
Coal Preparation Facility whose primary purpose is to remove, through a coal
washing process, the sulfur and ash from the coal. The coal washing process
reduces sulfur dioxide and particulate matter emissions, which are regulated air
pollutants.
5.
Section 11-10 ofthe Property Tax Code,
35
ILCS 200/11-10 (2002), defines
“pollution control facilities” as:
“any system, method, construction, device or appliance appurtenant thereto, or
any portion ofany building or equipment, that is designed, constructed, installed
or operated for the primary purpose of: (a) eliminating, preventing, or reducing air
orwater pollution.., or (b) treating, pretreating, modifying or disposing ofany
potential solid, liquid, gaseous pollutant which ifreleased without treatment,
pretreatment, modification or disposal might be harmful, detrimental or offensive
to human, plant or animal life, or to property.”
- - -
6.
Pollution control facilities are entitled to preferential tax treatment, as provided by
35 ILCS 200/11-5 (2002).
- -
7.
Based on information in the application and the underlying purpose ofthe
facilities to prevent, eliminate or reduce air pollution, it is the Illinois EPA engineering judgment
that the described facilities may be considered as “pollution control facilities” in accordance with
the statutory definition and consistent with the Board’s regulations at 35 Ill. Adm. Code 125.200.
-
8.
Because the described facilities satisfy the aforementioned criterion, the Illinois
EPA recommends that the Board issue the applicant’s requested tax certification.
Respectfully submitted,
ILLINOIS ENVIRONMENTAL PROTECTION AGENCY
By:
~7~o
~‘
Robb H. Layman
Special Assistant Attorney General
ARDC #6205498
DATED: December 16, 2003
ILLINOIS ENVIRONMENTAL PROTECTION AGENCY
1021 North Grand Avenue East
P.O. Box 19276
Springfield, Illinois 62794-9276
Telephone: 217/782-5544
Facsimile: 217/782-9807
THIS FILING IS SUBMITTED ON RECYCLED PAPER
PROOF OF SERVICE
I, the undersigned, certify that I have served the attached Appearance and
Recommendation upon the person to whom it is directed, by placing them in an envelope
addressed to:
TO:
Dorothy Gunri, Clerk
Donald Coovert
Illinois Pollution Control Board
5949
Beau Jardine Drive
•
State ofIllinois Center
Indianapolis, Indiana 46237
100 W. Randolph Street, Suite 11-500
Chicago, Illinois 60601
Steve Santarelli
Illinois Department ofRevenue
101 West Jefferson
P.O. Box 19033
Springfield, Illinois 62794
-
and mailing it by First Class Mail from Springfield, Illinois on December 16, 2003. A copy of
the attached documents was also filedby facsimile with the Board on this same date.
••
Robb H. Layman
6”
Special Assistant Attorney General
ARDC#6205498
THIS FILING IS SUBMITTED ON RECYCLED PAPER
- -
Peabodq
DAVID R. JOEST
Counsel
PEABODY ENERGY
1970 Barrett Court
P.O.
Box 1990
Henderson, Kentucky 42419-1 990
270.827.0800
270.827.6221
(Writer’s Direct)
270.827.6278 (Fax)
Mr. Donald E. Sutton
Permit Section
Division of Air Pollution Control
Illinois Environmental Protection Agency
P.O. Box 19276
Springfield, Illinois 62794-9276
October
14,
2003
RE:
Arciar
Company, LLC
Willow Lake Preparation Plant
Application
for
Certification of
Pollution Control Facility -
(Air) (Property Tax Treatment)
Dear Mr. Sutton:
Enclosed please find an original and one copy of Arclar Company, LLC’s -
application for certification of its Willow Lake Preparation Plant as an air pollution
control facility.
Arciar has designated Donald Coovert as its representative for purposes
of contact and receipt of the certification. Mr. Coovert’s address and telephone
number appear in the application. Please contact him if you require any further
information.
Very truly yours,
Enclosures
cc:
D. Coovert
A. Jackson (w/o end)
—
~.Uh~-t-
IA
LLC
~
r
oc~ ~
~.•
C~klDslaUOEST’Arcl5r
PcUuljan
File
Lelter.doc
This
Agency is authorized to request this
information under Illinois Revised Statues, 1979,
Chapter, 120, Section
502a-5.
Disclosure ofthis
information is voluntary. However, failure to
comply could prevent your application from
being processed or ~uld result in denial ofyour
application for certification.
APPLICATION FOR CERTIFICATION (PROPERTY
TAX
TREATMENT).
POLLUTION CONTROL FACILITY
AIR~
WATER
0
ILLINOIS ENVIRONMENTAL PROTECTION AGENCY
P.
0.
Sox
19276,
Springfield,
IL 62794~9276
FORAGENCY USE
File No. ,
Date Received
derti~cationNo,
Date
Sec..A.
•
..
~
~
~
Company Name
Arelar Company, LLC
Donald Coovert
Person Authorized to Receive Certification
Person to Contact for Additional Details
Donald Coovert
Donald Coovert
Street Address
Street Address
5949 Beau Jardine Drive
5949 Beau Jardine Drive
Municipality,
State & Zip Code
Municipality, State & Zip Code
Indianapolis, IN 46237
Indianapolis, IN 46237
Telephone Number
Telephone Number
(317) 781-2950
(317) 781—2950
Location of Facility
Municipality
Township
Quarter Section
Township
Range
SW
~?
Sec. 1
9S
7E
Cottage
Street Address
County
Book Number
420
Long Lane Road, Equality, IL 62934
Saline
Property Identification Number
Parcel Number
-
Sec. B
(5
~
~
~:
~
~
~O
Nature of Operations Conducted at the Above Location
Underground coal mine portal and coal preparationplant
and loadout.
Wa er Pollution Control Construction Permit No.
N)A
Date Issued
-
•
NPDES PERMIT No.
IL 0066664
.
Date Issued
Expirabon Date
June 30, 1999
March 31, 2004
Air Pollution Control Construction Permit No.
165802 ~
Date Issued
July 29, 2002
Air Pollution Control Operating Permit No.
165802AAB
Date Issued
August 1, 2003
Sec. C
~
~
~
Describe Unit Process
• •
-
Coal washing facility that removes ash, rock and sulfur from the raw
- -
coal product to produce a clean coal product.
Materials Used in Process
Raw coal/water/magnetite/floculant
Sec. D
~
~
~1
c:~:
cl,
U.
Describe Pollution Abatement Control Facility
Please see Flow Chart of Prepration Plant and Description of Prep
Plant Process.
,~•_~f
•-~
,7,
~
i~
-~
\
IL
532-0222
APC
151
(Rev.
8/00)
Tax Certificationfor Pollution Cor.rrol Facilities
—
Page! of2
8/00
Sec. E
(1)
Nature of Contaminants or Pollutants
.
I-
-~
0
IL.
-J
0
I-
z
0
0
z
0
I-.
_2-LI--
0
0
z
I--
z
0
0
0
Tax Cer4flcationfor Pollution ControlFacilities
Page 2 of2
8/00
U)
I-
z
z
z
0
0
~l,irT-l7
~l00mesh materia
Material Retained, Captured or Recovered
Contarninantor Pollutant
DESCRIPTION
DISPOSAL OR USE
Coarse Refuse
Rock Waste
Trucked to Pit for dispos~
1
(2) Point(s) of Waste Water Discharge
See attached map for locations
Pumped to old works for
di sno sal
—
Plans and Specifications Attached Yes
X
No
Are contaminants (or residues) collected by the control facility?
Yes
X
No
(4)
Date installation completed . 4.LZQQ2..,_____status of installation on date of application
(5) a. FAIR CASH VALUE IF CONSIDERED REAL PROPERTY:
$
3,500,110.00
b. NETSALVAGEVALUEIFCONSIDEREDREALPROPERTY: *
$ 0
—
c. PRODUCTIVE GROSS ANNUAL INCOME OF CONTROL FACILITY:
$
0
—
d. PRODUCTIVE NET ANNUAL INCOME OF CONTROL FACILITY:
$ O
e. PERCENTAGE CONTROL FACILITY BEARS TO WHOLE FACILITY VALUE:
100
Sec. F
~
Th~foIlowinginformation is submitted in accordance with the Illinois Property Tax Code, as amended, and to the best of my
knowledge, is true and correct. The facilities claimed herein are “pollution control facilities” as defined in Section 11-10 of the
Illinois Property Tax
e.
!~I~1h
Signature
Title
Sec. G
INSTRUCTIONS FOR COMPILING AND FILING APPLICATION
General: Separate applications must be completed for each control facility claimed. Do not mix types (water and air). Where both air and
water operations are related, file two applications. If attachments are needed, record them consecutively on an index sheet.
- -
Sec. A
Information refers to applicant as listed in the tax records and the person to be contacted for further details or for inspection of
facilities. Define facility location by street address or legal description. A plat map location is required for facilities located
outside of municipal boundaries. The property identification number is required.
Sec. B
Self~explanatory.Submit copies of all permits issued by local pollution control agencies. (e.g. MSD Construction Permit)
Sec. C
Refers to manufacturing processes ormaterials on whichpollution control facility is used.
Sec. D
Narrative description of the pollution control facility, indicating that its primary purpose is to eliminate, prevent or reduce pollution.
State the type of control facility. State permit number, date, and agency issuing permit. A narrative description and a process
flow diagram describing the nollution control facility. Include a listing of each major piece of equipment included in the claimed
fair cash value for real property. Include an averace analysis of the influent and effluent of the control facility stating the
-
collection efficiency.
Sec. E
List air contaminants, orwater pollution substances released as effluents to the manufacturing processes. List also the final
disposal of any contaminants removed from the manufacturing processes.
Item (1)— Refers to pollutants and contaminants removed from the process by the pollution control facility.
Item (2)— Refers to water pollution but can apply to water-carried wastes from air pollution control facilities. Submit drawings,
which clearly show (a) Point(s) of discharge to receiving stream, and (b) Sewersandprocess~p~oingto and from the control
facility.
tern (3)—If the collected contaminants are disposed of other than as wastes, state the disposition of the materials, and the value
in dollars reclaimed by sale or reuse ofthe collected substances. State the cost of reclamation and related expense.
Item (4)— State the date which the pollution control facility was first placed in service and operated. If not, explain.
Item (5) — This information is essential to the certification and assessment actions. This accounting data must be completed to
activate project review prior to certification by this Agency.
Sec. F
Self-explanatory. Signature must be a corporate authorized signature.
Submit to:
Attention:
Attention:
lilincis EPA
Thomas McSwiggin
Donald E. Sutton
P.O. Box
19276
PermitSection
Permit Section
Springfield, IL
62794-9276
Division ofWater Pollution Control
Division of
Air
Pollution Control
*
Cost of reclamation exceeds salvage value.
4” FLOOR - ELEV. 460
1)
Head Pulley - Feed at 1200 tons/hr. Flop gate splits the feed evenly.
2)
Maci Separator - Recovery of heavy media Magnetite (6X density of water).
3)
20’ Cyclones (6 ea.) feed from sumps 6 & 6A underflow to refuse, overflow to thickener tank.
4)
15’ Cyblones (10 ea.) feed from sumps 1 & 1A. Underflowtotriple start spirals. Overflow to sumps 6 & 6A.
5)
10’ Cyclones (3 ea.) feed from sump 8. Underflow to fine coal screens (-100 M). Overflow to thickener tank.
3rd
FLOOR- ELEV. 438
1)
Raw Coal Screens, 2 each, lOx 20’, (desliming screens). Separates coal at 3/8”. Plus 3/8” to heavy
media
vessel. Minus 3/8 to heavy media cyclone.
2)
Heavy Media Vessel - Specific gravity of 1.45 to 1.55 separates coal and non-coal. Coal goes to coarse coal
screens. Non-coal to coarse refuse screen. Heavy media vessel feeds from No. 2 sump.
3)
Heavy Media Cyclone (40 inch) feed minus 3/8” material from Sump No. 5. Coal goes out the overflow to
small coal screens. Non-coal goes out underflow to horizontal refuse screen. Operates at 1.45 to 1.55
specific gravity.
-
4)
Spirals - Two triple starts and one double start. Feed from 10~’cyclones. Separates into coal, middlings, and
refuse. Coal to fine coal screens, middlings to No. 7 Sump (double start spirals), refuse to fine refuse screens.
2~FLOOR - ELEV. 41 4/418
1)
Fine Coal Screens (3 ea., 5’x 12’) Filter water and fines from coal. Feed from 15” cyclones. Fines aridwater
to No. 8 Sump (10” cyclone feed). Coal goes to CMI 42” centrifugal dryers.
2)
Small Coal Screens (2 ea., 6’x 20’) Feed from 40” heavy media cyclone. Discharge to two each Tema dryers.
Heavy media recovered and sent to Mag separators.
3)
Coarse Coal Screens (2 ea., 6’ x 20’) Feed from heavy media vessel. Separates coal at
+¾”
to clean coal belt,
minus ¾”to two each Tema dryers. Heavy media recovered and sent to Mag separators.
4)
Fine Refuse Screens (2 ea., 5’x 12’) Feed from 20’ cyclones and spirals. Dewatered material to refuse beft-, -
fines and water to thickener tank.
5)
Horizontal Refuse Screen (1 ea., B’x 16’) Feed from 40” heavy media cyclone. Dewatered material to refuse
belt, fines and water to heavy media circuit or Mag separators.
6)
Coarse Refuse Screen (1 ea., lOx 20’) Feed from heavy media vessel (non-coal). Dewatered material to
refuse belt, fines, water and heavy media back to heavy media circuit or Mag separators.
1~FLOOR - ELEVATION 400
1)
Fine Coal Dryers (2 ea., 42” CMI dryers) Feed from fine coal screens. Dry coal to clean coal belt. Water and
fines to 10” cyclone Feed Pump No. 8.
2)
Coarse Coal Dryers (2 ea. Tema 1300 dryers) Feed from coarse coal (-¾”)and small coal screens. Dry coal
to clean coal belt. Water, fines, some heavy media back to Mag separators.
.
3)
Refuse Belt - Feed from 2 each fine refuse screens; one each horizontal refuse screen; and one each coarse
refuse screen.
‘aLNWCL~1W.MWM~
IS~sCm nW ,aaTm ‘aLT.
MO OTJOM’COOflLOLT.
ci
~i’”°
9
i”””
LOT
‘‘03’
(31~0
a
flu
—
co~
--
CLfM CO
T
—TONMIOUg
O
-
OCL5.T41NT120
MU
-
MiIUMTT~&
~
‘“~°
-
D.~
DrN5tTYMtOTK
~VALV!
~ —SOLOYWT.
3.M~SUL.
MOCT.
50 —OPTOPICGP.NVIT?
U
M~3H
2
~-
IICTND
~i’
-.~
II
‘sit
53354
~,
••~••~ifl)
II
o,a.Az,. C\OLOLO
(0
4~‘aUTO
,awIAC,uo,e
U,
is,
-
“—
10
LT0T
02400
“~
—
—
‘:t~
‘it~3
-“‘-
—
~
-~
~i,_,
~t00
sat
_~3
-
~
~
L~ ll~jI
t1~
(U
U
‘2’
05C
_1~
I—
___ ______
Ttia
E’~~
__
~
--
1~1I ~
—
___
__
I
1:~~!l
I -
=
~-
5335C
“U.’..,
200
ItS
-
=rJ
~,II
(2(53.05 (2(54405
204
(aT
32IU
0 01.145
(70400(
___________
~ snot
~
(2(543.25 (2(5545
•00O~~
it 05001
-‘
0100s
i~r__
w~Ov.O~
,~‘:‘::~
i300
—
O)(23IIW.ThQD~U
L:;~~.~1~
‘‘
2
HOO
F’R~LIMlWARY
/ INCOMPLLTE
(ZOO TPTI T.AW row
roCfOSCo cOAL
WASMING ?W1r
now eAILW. p1e,kV~’M~AC~tO~f5
-lOIN. 433 (U. N.M. CYGONOS
LOOn COMWO’.
~LC
23 0t3~
tUflA000 ‘a
IEfl2Cl~I
ATTACHMENT NO. 1
UNDERGROUND
SOLID REFUSE DISPOSAL
FLOW
CHART
CLEAR OVERFLOW
RECOVERY WELL
INJECTION WELL
SLURRY
RECOVERY WELL
INJEC11ON HOLE
PERMIT NO. 347
NO. 5
PERMIT NO. 347, IBR NO. 6
sJECTIOF’l HOLES
PERMIT NO. 347,
IBR NO. 2
PERMIT NO. 347,
IBR NO. 3
INJEC11ON HOLE
PERMIT NO. 347,
IBR NO. 4
0
0
0
1’
cp
PERMIT NO.
IBR NO. 1
OUTFALL
Oil
OUTFALL 013
SCALE 1:24,000
0
1000
-
-j
USGS MAP ELDORADO, IL
LOCATION MAP
ARCLAR CO. tiC
BIG RIDGE MINE
HARRISBURG, IL
OUTFALL 014
Peobodq
1970
Barrett Court
PE4~ODYENEROY
P.O. Boo 1950
Henöer~~nKeatucky1
42419.1
99o
270.827.0800
DAViD ft.
JOEST
270.827.6221 (Writer’s DJree~
Cooa,od
270.827.8278
(Fax)
October
14,
2003
Mr.
Donald E. Sutton
Permit Section
•
DMsIon of Air Pollution Control
Illinois Environmental Protection Agency
P.O.
Box
19276
Springfield, illinois 62794-9276
RE:
ArclarCornpany~LLC
Willow Lake Preparation Plant
Application for Certification of Pollution Control Facility
(Air) (Property Tax Treatment)
-
Dear Mr. Sutton:
Enclosed please find an original and one copy of Arciar Company, LLC’s
application for certification of its Willow Lake Preparation Plant as art air pollution
control facility.
Arclar has designated Donald Coovert as its representative for purposes
of contact and receipt of the certification. Mr. Coovert’s address and telephone
number appear in the application. Please contact him If you require any further
information.
Very truly yours,
Enclosures
cc:
D. Coovert
A. Jackson
(wlo
end)
LLC
C~tsIJOETWclsrPd1ueOflI’~aLa~.doe
T~oC.rrWkattonfrPoltutiors Co~sPvZFac~dit.~.r
Pare! of2
ThTs
A~ency is ar~thorized tO rvqucst this
~fon~i~ontonderillinois
~i~od
S1~uig,)979,
Q~ap~r,
110,Secsi~s
~
~tsc1ostre
ofthis
i~rmstionis
vv!~mlsty. Huweve~,
(aihuc to
co~npIycould
pc~t yctw s~pIica~on~roi~
being
prooes~cd
or could rcsuit In denisiof
your
z~1icationforccrti5caflofl.
APPLICATION FOR
CERTIFICA11ON (PROPERTY TAX TREATMENT)
POLLUTION CONTROL
FACILITY
AIRS.
WATERO
ILLINOIS ENVIRONMENTAL
PROTECTION AGENCY
P.O.
Box 1~276,SpringfIeld,
IL
62754.9276
FLD.
FOR
AGENCY
USE
File
No.
Data
Received
CertificeUon
No.
.. -
Sec.A
--
~
• .;
~_
• .~
~
~
ç
...,,
n~p~ny
Name
.
Arciar Company,
LLC
i~ojia1dCoovert
pQrson Authorized to
ReceIve
Certification
Person to Contact
for
Additional Details
Dosiald
Coavert
bonald Coovert
Street~ddiesi~
5fr~èt
Address
5949 Beau
Jardine Drive
5949 Beau Jardine Drive
Municipality, State & ZIP Code
MunIcIpality, State & Zip Code
it~s~t’
CT~.7
Indianapoli.e,
LR
46237
Indianapolis, IN 46237
Telephone t’Jumber
TeIe~hone
Number
~‘fl\/ 1
(317)
781—2950
(317) 781-2950
IIU’l
‘.~
LocatIon orFacHlty
Municipality
Township
Quarter
S~t1on
Thwnship
Range
SW 3, Sec. 1
95
7g
Cottage
street Address
~ou~ty
Book Number
.....420
Long Lane Road, Equality, IL 62934
.
Saline
Property Id~bflcati~WNumbar~
ParcelNumber
L~i~~’
~.Q~7L)
Sec. B
L0
~
~
~
~O
a
N~iè-e~Q~rationeConducted at the
.A~aVe
Location
-
~
and coal preparation plant arid loadout.
Water
Pollution Control Construction Permit No.
N/A
Date Issued
.
i~1PbE~PERMItNo.
IL 0066664
Date Issued
-
I E,çiration
Date
-
June
30,
1999
March 31,
2004
Air
PollutIon Control
Construction Permit
NO.
165802 AAB -
Date Issued
July 29,
2002
Air Pollution Control
Operating Permit
No.
165BOZAAB
Data
Issued
August 1, 2003
Sec. C
~,
~
E
Dezcribe
UnIt
Process
Coal washing
facility that removes
ash, rock and
sulfur from
the raw
coal product to
produce a clean
coal product.
-
-
P~1iteriaIsUsed in Process
Raw coal/water/~agnetite/flocu1ant
Se~D~
-
~
~
z
Q
~
..~
2~
0
~e~ctibèPollution
Abatement Control
Facility
-
Please see Flow
Chart
of Prepration Plant and Description of Prep
Plant
Process.
-
- -
IL
532.0222
APC 151
(Rev.
8/00)
Sec. ~ (1) Nature
of Contaminar~teor Pollutants
L
I.-
0
ci
Crr~ifica!io~forPoibatonConb~,iFC411~.JS
Fags
2
of
2
8/00
Material Retained. Ceotured
or Recovered
L
Contaminant or
Pollutant
DESCRIPTION
DISPOSAL OR USE
Coarse
Refuse
-
Rock Waste
Trucked to Pit for dispos~
Slurry
-
100• mesh materia
Puaiped
to old works for
dispoaal
-
(2)P.oint~s)
of
Waste Water Discharge
See
attach~~p
~1ocations
-
Plans and SpecIfications Attached
Yes
- x
LNO - —-
1~LAre contaminants (or residues) collected
by the control
facility?
-
Yes
X
I
No
(4)
Date installation completed
4/2002
status of Installation on date of application
~.ç.~ti11g
—
(5) a. FAIR CASH
VALUE
IF CONSIDERED
REAL PROPERTY:
$ 35Q~11OQQ
•
b. NETSALVAGEVALUEIFCONSIDEREDREALPROPERTY:
*
$ 0
c. PRODUCTIVE GROSS ANNUAL INCOME OF CONTROL FACILITY:
d. PRODUCTIVE NET
ANNUAL
INCOME OF CONTROL FACILITY:
$
6
e. PERCENTAGE CONTROL FACILITY BEARS TO
WHOLE
FACILITY VALUE:
100
Sec.
F
~
~
Sec. G
~T’i~roUowlngInformation Is submitted in accordance with
the Illinois
Property Tax Code,
as amended, and to the
besf~~
knowledge, Is
true
and
correct. The facilities
claimed
herein are ~poIluti~n
control faculties as defined in Section 11-10 of-the
IllinoIs
Property lax
e.
--
Signature
Title
-
INSTRUCTION$
FOR COMPILING AND FlLlN~
APPLICATION
General: Separate application, must be completed fcc each control facility ciairned.
Do not
mix types (water and air). Where both air acid
water operatons
are
related, file two ap~licationz,If attachments are needed, record them consecutively
on an tnde
~h~et.
Sec.
A
In(ormanon
raters to
applicant
as tlstaU In aie
te~racortis and o’e person to be ccntaet 4~oe~t~cr~detaUaor for inspectiortot -
facilities. DefIne facility location
by
strat address or legal des~ip~on.
A plat map
location is required for facilities located
outside of municipal boundaries.
The
property Identification number
is
required.
Sec.B
Self-e~planato~,.Submit copies Of allpermits Issued
by
local pollution control agencies. (e.g.
MW
Construction Permit)
Sec.
C
Ref~
to manufaciurirrg processes ormateials
on
which pollution control faclihty leusad.
Sec. D
N
deecciption ofthe pollution controlfacility, hidicarlng that Its primary purpose Is to eliminate~pze~torrtduccpolIuton.
State (he type
of çoi*~l
racirny. StalepermIt nurnbec date, and agency Issubig permit. A narrative descrlØori and a proce~
howdiagram
des~dbingthe
oollution control façwrty, Inducie
a
listing of each major piece of equipment Induded
inthe
CisI~~~ed
fair cash
value for real
property. Include
an
~
enal~Is
of
the
influecit and
effluent of
the control rcci1~ystating
the
e~
~
~
~
~
~
collectIon efficiency.
Sec. E
List air contaminants, cc wat~pollution substances released as elfluentz to the manufacturing processes-.
Lst also the tinal
disposal
of any
contaminants removed from
the
manufacturing
processes.
-
Item (1)- Refers to pollutants and contaminants removed frohi the process by~icontrcl~dliP/
Item (2) —
Refers to water
pollution but can apply to wter.r;rried wastes from aIrpollutIon control fadttiee. Submit drawin~
which clearly show (a) PoInt(s)of discharge to reOelvlng stream, and (b) Sewers and process piping to and from
the
control
facility.
Item (3)—If the collected contaminants are disposed ofother thanas waste,, state the disposition ofthe materials, and
the
value
In doliars reciafmed by sate
or
reuse or the collec~dsubstances. State the cost of reclamaton and related expense.
Item (4)— State thedate which
the
pollution control facility was llr~tplaced in service-arid operated. lthc~explain.
Item
(5)—This
information is essential to the certification and assessment acdons. This accounting data must be completed to
a~vatepr~je~t
review pcior to certification
by
this Agency.
See, F
Self-explanatory, Signature must be a corporate authorized signature.
-
-
Submit to:
• Attentlom
• Attention:
IJlrloi5
EPA
Thomas McSwtggin
Donald E. Sutton
-
P.O.
BOX 19273
Permit Section •
Permit Section
Springfield, IL 62794-9276
• DMsicnofWater Pollution Control
- DivIsion ofAir PollUtiçn Control
*
Cost
of reclamation exceeds salvage value.
~f
Venture
949
J
Th~I~
ManagementIntern
ationa4
LtL
!rdith-,apd5~IN
46237
(317) 781.29.50
P~:
(317) 781.2948
-ftjath
A~Cooi~oLcoin
Fagcs,includingcover
Fax
Cover Sheet
fg~\’F11)ENTlALAND
PRUPRIPTARY INFORMATION
This document contains information, which isprFvilegec~praprietaiy
o.nd
confidentiaL
ft isfor the rxdusive use ofshe
addressee only. Please
note
that distribution, dissemination, copying or use
of
thL~docwnznt, or the concepts
contained within L~.stricdy prohibited (fyou have received this docu~nern
In
error, please telephone immediately
to
arra’i~è
for prompt
return-
FAX NUMBER:
DELtVERTO:
COMPANY:
DATE:
-
RECrPIENT’S PHONE:
SENDER:
PHONE:
FAX:
R1~T’TP1ENT
1N1~ORMAT1ON
~Wck~~1
NO’! I
-
?O1i,~:
VOICE
MAILIPAOINO:
CELL PHONE:
ALTERNATE
PHONE:
c~
&~O—~~)~
~iTh4~1k~
~Q~-+~
~A~C±k
~
±~
~
-
c
-
L ~-~-
~
~
k
- ~-
(~
~
~
~
u1~(o~
h
H~
S1~NDER
1~FORMATTON
~V
~
..
-
--
-
A
hard
copy of
this document
-
will be sent by
regularmail.
will
be sent
via
overnight
mail.
will not be sent under separate
cover.
COMMENTS:
(S
STATUS:
.~-
Urgent
For Your Review
Reply
ASAP
Please Comment
Ft~ct:
SQ(c(
~
~
-~r~c..t.(c~1
ccRc~tc~~ ~
~‘RTh~
‘ZV\~k-
y-’~v~p.
p(~$-~
6
\cAQ\1
O~Ov\
A c~-~
WF+
-fkc2~~
*~-i
(~1TE~V~
~H~
\~fôL) ~
A~A~t~d
~Jow:
I
1A~~
Os-k
(c(z~3
~
~
Co~y
-
Ve.~-~\idQr\
F CVA(o~
~b3,222~-
~
~7~3-o-Of-~~
2~
~~
-wt
~
-~Att~c\
A~7k
O~J
~‘L4tJQ
A~t
+k _A~(Z~Th~
~7
tll~,
Aks~~
~(I
~Qf~Qk~
~
~Q(1
f?yo~~cz~o~
~
~A~
~
- -
~
~ou~
-
NOV
1
--
~c)~
~
-~
~
ye?..0
t—3o.~l4~’Q
—
-~--~
-~-——
-U
