ILLINOIS POLLUTION CONTROL BOARD

September

24,

1987

IN THE MATTER OF:

VOLATILE ORGANIC MATERIAL

)

 R82-14

EMISSIONS

 FROM STATIONARY

SOURCES:

 RACT

III

ADOPTED

 RULE

 FIi~ALORDLR

ORDER OF THE BOARD

 (by B.

 Forcade):

ORDER

The Clerk

 of the Pollution Control Board

 is directed to

submit the following adopted rule

 to the Secretary of State

for

final

 notice:

TITLE

35:

 Li~VIRGNNLNTALPROTECTION

SUBTITLE

B:

 AIR POLLUTION

CHAPTER

1:

POLLUTiON

CONTROL

BOARD

SUBCHAPTER

c:

 EMISSION STANDARDS AND

LIMITATIONS

FOR STATIONARY

 SOURCES

PART

215

ORGANIC MATERIAL

 EMISSION STANDARDS

 AND LIMITATIONS

SUBPART

P:

 PRINTING AND PUBLISHING

Section

215.401

 Flexographic and Rotogravure Printing

215.402

 Exemptions

215.403

 Applicability

 of Subpart

K

215.404

 Testing

 and Monitoring

215.405

 Compliance Dates

 and Geographical Areas

215.406

 Alternative Compliance

 Plan

215.407

 Compliance

 Plan

215.408

 Heatset

 ~eb Offset Lithographic Printing

Section 215.405

 Compliance

 Dates and Geographical Areas

a)

 Except as otherwise stated

 in subsection

 (b),

 every

owner

 or operator

 of an emission source subject

 to: th~

sF~e~iee~~p~y

with

adar~

~nd

m-~tatiens

by Beee~be~3~ ~9?~

1)

 Section

 215.401 shall comply with

 its standards

and

limitations

 by December

31,

 1983;

and

81—399

2)

 Section

215.406

 shall

 comply with

 its standards and

—

 limitations by December

31,

 19b7.

b)

If

 an emission source subject

 to Section 215.401

 is not

located

 in one of the counties listed below

and

 is also

not

 located

 in any county contiguous thereto,

 the owner

or operator

 of the emission source shall comply with the

requirements

of

 this Subpart

 no later

 than December

31,

1987:

Cook

 t’lacoupin

DuPage

 Madison

Kane

 Monroe

Lake

St.

 Clair

+Boa~ Nete-~ These eoei~t~esa~epro~ose~to be

~es-i~ate~

 es r~eftatt

 nmerit by the USEPA ~?4~ Fe~ Re~-~

~I5887

 ~t~Iy2~-~982+-~

c)

 Notwithstanding

 subsection

 (b),

 if any county

is

designated

 as nonattainment

 by the USEPA at any time

subsequent

 to the effective date

 of this Subpart,

the

owner

 or operator of

 an emission source located

 in that

county

 or any county contiguous

 to that county who would

otherwise

 be subject

 to the compliance date

in

subsection

 (b) comply with

 the requirements of this

Subpart within one year

 from the date of

 redesignation

but

in

 no case later

 than December

31,

 19b7.

(Source: Amended at

 Ill. Reg.

 effective

____________

Section 215.407

 Compliance

 Plan

a)

 The owner

 or operator

of

 an emission source subject

to

Section 215.405(a) (1)

 shall submit to the Agency a

compliance plan, pursuant

to

35

 Ill. Adm.

 Code

 201,

Subpart

H,

 including

 a project completion schedule where

applicable,

no

 later

 than April

 21, 183.

b)

 The owner or operator

 of an emission source subject

to

Section

 215.405(b)

 shall submit

to

 the Agency

a

compliance plan,

 including

 a project completion schedule

where

 applicable,

 no later

 than December

31,

 1986.

c)

 The owner

 or operator

 of an emission source subject

to

Section 215.405(c)

 shall

 submit

 a compliance plan,

including

 a project completion schedule within

 90 days

after

 the date of

 redesignation,

but

 in no case later

than December

31,

 1986.

81—400

d)

 Unless

 the submitted compliance plan

or

 schedule

is

disapproved

 by the Agency,

 the owner or operator

of

a

facility

or

 emission source subject

to

the

 rules

specified

 in subsections

 (a),

(b)

or

 (c) may operate the

emission source according

to

 the plan and schedule as

submitted.

e)

 The plan and scnedule

 shall

 meet the requirements

of

35

Ill.

 Adm.

 Code

 201,

 Subpart

H,

 including specific

interim dates

 as required

in

35

 Ill. Adm.

 Code

 201.242.

(Source: Amended

at

 Ill.

 Reg.

 effective

____________

Section

 215.406

 heatset ~eb Offset Lithographic Printing

a)

 owner

 or operator

of

 a heatset web offset

lithographic printing facility,

 located

in

 Cook,

 DuPage,

Kane,

 Lake, Macoupin,

 Madison, McHenry, Monroe,

St.

Clair

 or hill County,

 emitting over

 100 tons/year

of

organic material,

in

 the absence

 of pollution control

equipment,

 may cause

 or allow

 the operation

of

 a ‘neatset

web offset press

 unless:

 An incinerator

 system

 is installed and operated

that oxidizes at least

 90 percent of

 tne organic

materials

 (measured

 as total combustible carbon)

in

the dryer exhaust airstream

 to carbon dioxide

and

water;

or

2)

 The fountain solution contains

 no more

 than eight

 (8) percent,

 by weignt,

 of volatile organic

material and

 a condensation

 recovery system

is

installed

 and operated

 tnat removes at

 least

75

percent

of

 the non—isopropyl alcohol

 organic

materials from the dryer

 exhaust airstream.

b)

No

 owner

or

 operator of

 a heatset web offset

lithographic printing facility,

 located

in

 a county

other

 than

 Cook,

 DuPage,

 Kane,

 Lake,

 Macoupin,

 Madison,

Mcbenry,

 Monroe,

 St. Clair

or

 pill County,

 emitting

 over

100 tons/year

 of organic material,

 in the absence

of

pollution control equipment, may cause

or

 allow

the

operation

of

 a heatset web offset press

 unless the

fountain solution contains

 no more than eight

 (6) per-

cent,

 by weight,

 of volatile

 organic material.

(Source: Added

at

 Ill.

 Reg.

 effective

____________

IT

IS

 SO ORDERED

81—40 1

—4—

I, Dorothy M.

 Gunn,

 Clerk

 of the Illinois Pollution Control

Board,

 hereby certify

 that the abo-~eAdopted Rule, Final Order

was adopted on the ~

day

of

:/—~L~

 1987,

 by a vote

of

Dorothy M. ~Gunn, Clerk

Illinois Pollution Control Board

81—402