ILLINOIS POLLUTION CONTROL BOARD
October 19, 2000
IN THE MATTER OF:
WASTEWATER PRETREATMENT UPDATE, USEPA
REGULATIONS
(January 1, 2000, through June 30, 2000)
)
)
)
)
)
R01-5
(Identical-in-Substance
Rulemaking - Water)
Proposed Rule. Proposal for Public Comment.
OPINION AND ORDER OF THE BOARD (by N.J. Melas):
Pursuant to Sections 7.2 and 13.3 of the Environmental Protection Act (Act) (415 ILCS 5/7.2 and
13.3 (1998)), the Board proposes amendments to the Illinois wastewater pretreatment regulations. Section
13.3 of the Act provides for quick adoption of regulations that are identical-in-substance to federal
wastewater pretreatment regulations adopted by the United States Environmental Protection Agency
(USEPA) pursuant to Sections 307(b), (c), and (d) and 402(b)(9) of the Federal Water Pollution Control Act
(FWPCA) (33 U.S.C. §§ 1317(b), (c), (d), 1342(b)(9) (1996)). Section 13.3 of the Act also provides that Title
VII of the Act and Section 5 of the Administrative Procedure Act (APA) (5 ILCS 100/5-35 and 5-40 (1998)),
do not apply to this rulemaking. Accordingly, this rulemaking is not subject to first or second-notice review
by the Joint Committee on Administrative Rules (JCAR).
Section 7.2(b) of the Act (415 ILCS 5/7.2 (1998)) requires the Board to complete its identical-in-
substance rulemaking actions within one year of the date of the earliest federal amendments involved in a
docket. In this docket, the earliest federal action requiring Board action occurred on January 19, 2000.
Thus, the Board must complete its rulemaking activity in this docket prior to January 19, 2001.
FEDERAL ACTIONS CONSIDERED IN THIS RULEMAKING
This proposed rulemaking incorporates certain federal amendments that occurred during the
period of January 1, 2000, through June 30, 2000. The federal wastewater pretreatment regulations are
found at 40 C.F.R. §§ 400-499, interspersed throughout the federal wastewater effluent discharge rules.
The USEPA amended its wastewater pretreatment regulations five times during that period: January 19,
2000; January 27, 2000; March 16, 2000; March 21, 2000; and May 23, 2000. This rulemaking incorporates
all of these actions.
The federal amendments incorporated into this rulemaking are summarized as follows:
Federal Action
January 19, 2000
(65 Fed. Reg. 3008)
January 27, 2000
Summary
Effluent Limitations Guidelines, Pretreatment Standards,
and New Performance Standards for the Landfills Point
Source Category. The USEPA adopted wastewater
effluent limitation guidelines, pretreatment standards, and
new source performance standards for the landfill point
source category. One segment of the rulemaking was the
amendment of Methods 625 and 1625 in 40 C.F.R. 136.3,
Appendix A.
Effluent Limitations Guidelines, Pretreatment Standards,
and New Performance Standards for the Commercial
2
(65 Fed. Reg. 4360)
March 16, 2000
(65 Fed. Reg. 14344)
March 21, 2000
(65 Fed. Reg. 15091)
May 23, 2000
(65 Fed. Reg. 33423)
Hazardous Waste Combustor Subcategory of the Waste
Combustors Point Source Category. The USEPA adopted
wastewater effluent limitation guidelines, pretreatment
standards, and new source performance standards for the
commercial hazardous waste combustor subcategory of
the waste combustors point source category.
Correction to
Effluent Limitations Guidelines,
Pretreatment Standards, and New Performance Standards
for the Landfills Point Source Category
.
The USEPA
corrected its January 19, 2000 (65 Fed. Reg. 3008) effluent
guidelines, pretreatment standards, and new source
performance standards for the landfill point source
category.
Amendment to
Effluent Limitations Guidelines,
Pretreatment Standards, and New Performance Standards
for the Builder’s Paper and Board Mills Point Source
Category. The USEPA removed its April 15, 1998 (63 Fed.
Reg. 18504) effluent guidelines, pretreatment standards,
and new source performance standards for the builder’s
paper and board mills point source category in 40 C.F.R.
431.
Correction to Effluent Limitations Guidelines, Pretreatment
Standards, and New Performance Standards for the
Commercial Hazardous Waste Combustor Subcategory of
the Waste Combustors Point Source Category. The USEPA
corrected its January 27, 2000 (65 Fed. Reg. 4360) effluent
guidelines, pretreatment standards, and new source
performance standards for the commercial hazardous
waste combustor subcategory of the waste combustors
point source category.
DISCUSSION
January 19, 2000: Effluent Limitations Guidelines, Pretreatment Standards, and New Performance
Standards for the Landfills Point Source Category; March 16, 2000:
Correcting Amendments to
Effluent Limitations Guidelines, Pretreatment Standards, and New Performance Standards for the Landfills
Point Source Category
Federal Action
The USEPA adopted wastewater effluent limitation guidelines, pretreatment standards, and new
source performance standards for the landfill point source category on January 19, 2000 (65 Fed. Reg.
3008). The regulation establishes technology-based effluent limitations for wastewater discharges associated
with the operation and maintenance of new and existing hazardous and non-hazardous landfills regulated,
respectively, under Subtitle C and Subtitle D of the Resource Conservation and Recovery Act (RCRA) (42
U.S.C. §§ 6901
et seq
. (1998)). Sources of landfill wastewater include, but are not limited to, landfill leachate
and gas collection condensate. One segment of the rulemaking was the amendment of Methods 625 and
1625 in 40 C.F.R. 136.3, Appendix A.
3
The USEPA adopted minor technical corrections to effluent limitation guidelines, pretreatment
standards, and new source performance standards for the landfill point source category on March 16, 2000
(65 Fed. Reg. 14344). Persons interested in a more detailed discussion of the January 19, 2000, and March
16, 2000 federal actions should refer to the cited
Federal Register
notices.
Amendment to Board Rules
The Board incorporates these amendments into its rules by adding “Subpart BT Landfills” to the
Part 307 Sewer Discharge Criteria. The Board also amends a single incorporation by reference to 40 C.F.R.
136 in the “Incorporations by Reference” Section found at 35 Ill. Adm. Code 310.107(b).
January 27, 2000: Effluent Limitations Guidelines, Pretreatment Standards, and New Performance
Standards for the Commercial Hazardous Waste Combustor Subcategory of the Waste Combustors Point
Source Category; May 23, 2000: Correcting Amendments to Effluent Limitations Guidelines, Pretreatment
Standards, and New Performance Standards for the Commercial Hazardous Waste Combustor Subcategory
of the Waste Combustors Point Source Category
Federal Action
The USEPA adopted wastewater effluent limitation guidelines, pretreatment standards, and new
source performance standards for the commercial hazardous waste combustor subcategory of the waste
combustors point source category on January 27, 2000 (65 Fed. Reg. 4360). The regulation generally applies
to hazardous waste combustion facilities, except cement kilns, regulated as “incinerators” or “boilers and
industrial furnaces” under RCRA (42 U.S.C. §§ 6901
et seq
. (1998)) under certain conditions.
The USEPA adopted minor technical corrections to effluent limitation guidelines, pretreatment
standards, and new source performance standards for the landfill point source category on May 23, 2000
(65 Fed. Reg. 33423). Persons interested in a more detailed discussion of the January 27, 2000 and May 23,
2000 federal actions should refer to the cited
Federal Register
notices.
Amendment to Board Rules
The Board incorporates these amendments into its rules by adding “Subpart BS Commercial
Hazardous Waste Combustors” to the Part 307 Sewer Discharge Criteria.
March 21, 2000: Removal of Effluent Limitations Guidelines, Pretreatment Standards, and New
Performance Standards for the Builder’s Paper and Board Mills Point Source Category
Federal Action
The USEPA removed its April 15, 1998 (63 Fed. Reg. 18504) effluent guidelines, pretreatment
standards, and new source performance standards for the builder’s paper and board mills point source
category in 40 C.F.R. 431 on March 21, 2000 (65 Fed. Reg. 15091). Persons interested in a more detailed
discussion of the March 21, 2000 federal action should refer to the cited
Federal Register
notice.
Amendment to Board Rules
The Board takes no action as a result of this amendment. The Board previously removed Subpart
BF, “Builder’s Paper and Board Mills” in R99-4 at 23 Ill. Reg. 4413, effective March 31, 1999.
4
Board Housekeeping Amendments
Section
Source
Revision(s)
307 Table of Contents
JCAR
Added “307.6505 Repackaging of Agricultural Pesticides
Performed at Refilling Establishments”
307 Authority Note
Board
Added Section “7.2”
307 Source Note
JCAR
Changed “:” to “;” after “July 12, 1999”
307.1503
JCAR
Changed “Seasoned Products” to “Cultured Products”
In Section 307.1503, the Board is amending the text of the title of the section to “Cultured
Products” from “Seasoned Products” to reflect the correct title in the table of contents and in corresponding
40 C.F.R. 405.30. In the table of contents, the Board is adding “307.6505 Repackaging of Agricultural
Pesticides Performed at Refilling Establishments” which corresponds to the text of the regulations. The
Board also changed a colon to a semicolon after “July 12, 1999” in the source note. These changes are being
made in response to a suggestion from JCAR, made on September 25, 2000. The Board added Section 7.2 of
the Act to the authority note.
Public Comments
The Board will accept public comments in this matter for a period of 45 days after publication of
the proposed amendments in the
Illinois Register
. After the expiration of the 45-day public comment period,
the Board will proceed to adoption of the regulations based on this proposal on or before the January 19,
2001 completion date specified by Section 7.2(b) of the Act.
ORDER
The Board adopts the following proposal for public comment. The Board directs the Clerk of the
Board to cause publication of the following proposal for public comment in the
Illinois Register
:
TITLE 35: ENVIRONMENTAL PROTECTION
SUBTITLE C: WATER POLLUTION
CHAPTER I: POLLUTION CONTROL BOARD
PART 307
SEWER DISCHARGE CRITERIA
SUBPART A: GENERAL PROVISIONS
Section
307.101
Preamble (Renumbered)
307.102
General Requirements (Renumbered)
307.103
Mercury (Renumbered)
307.104
Cyanide (STORET number 00720) (Renumbered)
307.105
Pretreatment Requirements (Repealed)
307.1001
Preamble
307.1002
Definitions
307.1003
Test Procedures for Measurement
307.1005
Toxic Pollutants
5
SUBPART B: GENERAL AND SPECIFIC PRETREATMENT REQUIREMENTS
Section
307.1101
General and Specific Requirements
307.1102
Mercury
307.1103
Cyanide
SUBPART F: DAIRY PRODUCTS PROCESSING
Section
307.1501
Receiving Stations
307.1502
Fluid Products
307.1503
Cultured Products
307.1504
Butter
307.1505
Cottage Cheese and Cultured Cream Cheese
307.1506
Natural and Processed Cheese
307.1507
Fluid Mix for Ice Cream and other Frozen Desserts
307.1508
Ice Cream, Frozen Desserts, Novelties and Other Dairy Desserts
307.1509
Condensed Milk
307.1510
Dry Milk
307.1511
Condensed Whey
307.1512
Dry Whey
SUBPART G: GRAIN MILLS
Section
307.1601
Corn Wet Milling
307.1602
Corn Dry Milling
307.1603
Normal Wheat Flour Milling
307.1604
Bulgur Wheat Flour Milling
307.1605
Normal Rice Milling
307.1606
Parboiled Rice Milling
307.1607
Animal Feed
307.1608
Hot Cereal
307.1609
Ready-to-eat Cereal
307.1610
Wheat Starch and Gluten
SUBPART H: CANNED AND PRESERVED FRUITS AND VEGETABLES
Section
307.1700
General Provisions
307.1701
Apple Juice
307.1702
Apple Products
307.1703
Citrus Products
307.1704
Frozen Potato Products
307.1705
Dehydrated Potato Products
307.1706
Canned and Preserved Fruits
307.1707
Canned and Preserved Vegetables
307.1708
Canned and Miscellaneous Specialties
SUBPART I: CANNED AND PRESERVED SEAFOOD
Section
307.1801
Farm-raised Catfish
307.1815
Fish Meal Processing Subcategory
SUBPART J: SUGAR PROCESSING
6
Section
307.1901
Beet Sugar Processing
307.1902
Crystalline Cane Sugar Refining
307.1903
Liquid Cane Sugar Refining
SUBPART K: TEXTILE MILLS
Section
307.2000
General Provisions
307.2001
Wool Scouring
307.2002
Wool Finishing
307.2003
Low Water Use Processing
307.2004
Woven Fabric Finishing
307.2005
Knit Fabric Finishing
307.2006
Carpet Finishing
307.2007
Stock and Yarn Finishing
307.2008
Nonwoven Manufacturing
307.2009
Felted Fabric Processing
SUBPART L: CEMENT MANUFACTURING
Section
307.2101
Nonleaching
307.2102
Leaching
307.2103
Materials Storage Piles Runoff
SUBPART M: FEEDLOTS
Section
307.2201
General
307.2202
Ducks
SUBPART N: ELECTROPLATING
Section
307.2300
General Provisions
307.2301
Electroplating of Common Metals
307.2302
Electroplating of Precious Metals
307.2304
Anodizing
307.2305
Coatings
307.2306
Chemical Etching and Milling
307.2307
Electroless Plating
307.2308
Printed Circuit Boards
SUBPART O: ORGANIC CHEMICALS, PLASTICS AND SYNTHETIC FIBERS
Section
307.2400
General Provisions
307.2401
Rayon Fibers
307.2402
Other Fibers
307.2403
Thermoplastic Resins
307.2404
Thermosetting Resins
307.2405
Commodity Organic Chemicals
307.2406
Bulk Organic Chemicals
307.2407
Specialty Organic Chemicals
307.2410
Indirect Discharge Point Sources
307.2490
Non-complexed Metal-bearing and Cyanide-bearing Wastestreams
307.2491
Complexed Metal-bearing Wastestreams
7
SUBPART P: INORGANIC CHEMICALS MANUFACTURING
Section
307.2500
General Provisions
307.2501
Aluminum Chloride Production
307.2502
Aluminum Sulfate Production
307.2503
Calcium Carbide Production
307.2504
Calcium Chloride Production
307.2505
Calcium Oxide Production
307.2506
Chlor-alkali Process (Chlorine and Sodium or Potassium Hydroxide Production)
307.2508
Hydrofluoric Acid Production
307.2509
Hydrogen Peroxide Production
307.2511
Potassium Metal Production
307.2512
Potassium Dichromate Production
307.2513
Potassium Sulfate Production
307.2514
Sodium Bicarbonate Production
307.2516
Sodium Chloride Production
307.2517
Sodium Dichromate and Sodium Sulfate Production
307.2520
Sodium Sulfite Production
307.2522
Titanium Dioxide Production
307.2523
Aluminum Fluoride Production
307.2524
Ammonium Chloride Production
307.2527
Borax Production
307.2528
Boric Acid Production
307.2529
Bromine Production
307.2530
Calcium Carbonate Production
307.2531
Calcium Hydroxide Production
307.2533
Carbon Monoxide and Byproduct Hydrogen Production
307.2534
Chrome Pigments Production
307.2535
Chromic Acid Production
307.2536
Copper Salts Production
307.2538
Ferric Chloride Production
307.2540
Fluorine Production
307.2541
Hydrogen Production
307.2542
Hydrogen Cyanide Production
307.2543
Iodine Production
307.2544
Lead Monoxide Production
307.2545
Lithium Carbonate Production
307.2547
Nickel Salts Production
307.2549
Oxygen and Nitrogen Production
307.2550
Potassium Chloride Production
307.2551
Potassium Iodide Production
307.2553
Silver Nitrate Production
307.2554
Sodium Bisulfite Production
307.2555
Sodium Fluoride Production
307.2560
Stannic Oxide Production
307.2563
Zinc Sulfate Production
307.2564
Cadmium Pigments and Salts Production
307.2565
Cobalt Salts Production
307.2566
Sodium Chlorate Production
307.2567
Zinc Chloride Production
SUBPART R: SOAP AND DETERGENTS
8
Section
307.2701
Soap Manufacturing by Batch Kettle
307.2702
Fatty Acid Manufacturing by Fat Splitting
307.2703
Soap Manufacturing by Fatty Acid Neutralization
307.2704
Glycerine Concentration
307.2705
Glycerine Distillation
307.2706
Manufacture of Soap Flakes and Powders
307.2707
Manufacture of Bar Soaps
307.2708
Manufacture of Liquid Soaps
307.2709
Oleum Sulfonation and Sulfation
307.2710
Air-Sulfur Trioxide Sulfation and Sulfonation
307.2711
Sulfur Trioxide Solvent and Vacuum Sulfonation
307.2712
Sulfamic Acid Sulfation
307.2713
Chlorosulfonic Acid Sulfation
307.2714
Neutralization of Sulfuric Acid Esters and Sulfonic Acids
307.2715
Manufacture of Spray Dried Detergents
307.2716
Manufacture of Liquid Detergents
307.2717
Manufacturing of Detergents by Dry Blending
307.2718
Manufacture of Drum Dried Detergents
307.2719
Manufacture of Detergent Bars and Cakes
SUBPART S: FERTILIZER MANUFACTURING
Section
307.2801
Phosphate
307.2802
Ammonia
307.2803
Urea
307.2804
Ammonium Nitrate
307.2805
Nitric Acid
307.2806
Ammonium Sulfate Production
307.2807
Mixed and Blend Fertilizer Production
SUBPART T: PETROLEUM REFINING
Section
307.2901
Topping
307.2902
Cracking
307.2903
Petrochemical
307.2904
Lube
307.2905
Integrated
SUBPART U: IRON AND STEEL MANUFACTURING
Section
307.3000
General Provisions
307.3001
Cokemaking
307.3002
Sintering
307.3003
Ironmaking
307.3004
Steelmaking
307.3005
Vacuum Degassing
307.3006
Continuous Casting
307.3007
Hot Forming
307.3008
Salt Bath Descaling
307.3009
Acid Pickling
307.3010
Cold Forming
307.3011
Alkaline Cleaning
9
307.3012
Hot Coating
SUBPART V: NONFERROUS METALS MANUFACTURING
Section
307.3100
General Provisions
307.3101
Bauxite Refining
307.3102
Primary Aluminum Smelting
307.3103
Secondary Aluminum Smelting
307.3104
Primary Copper Smelting
307.3105
Primary Electrolytic Copper Refining
307.3106
Secondary Copper
307.3107
Primary Lead
307.3108
Primary Zinc
307.3109
Metallurgical Acid Plants
307.3110
Primary Tungsten
307.3111
Primary Columbium-Tantalum
307.3112
Secondary Silver
307.3113
Secondary Lead
307.3114
Primary Antimony
307.3115
Primary Beryllium
307.3116
Primary and Secondary Germanium and Gallium
307.3117
Secondary Indium
307.3118
Secondary Mercury
307.3119
Primary Molybdenum and Rhenium
307.3120
Secondary Molybdenum and Vanadium
307.3121
Primary Nickel and Cobalt
307.3122
Secondary Nickel
307.3123
Primary Precious Metals and Mercury
307.3124
Secondary Precious Metals
307.3125
Primary Rare Earth Metals
307.3126
Secondary Tantalum
307.3127
Secondary Tin
307.3128
Primary and Secondary Titanium
307.3129
Secondary Tungsten and Cobalt
307.3130
Secondary Uranium
307.3131
Primary Zirconium and Hafnium
SUBPART X: STEAM ELECTRIC POWER GENERATING
Section
307.3301
Steam Electric Power Generating
SUBPART Y: FERROALLOY MANUFACTURING
Section
307.3401
Open Electric Furnaces With Wet Air Pollution Control Devices
307.3402
Covered Electric Furnaces and Other Smelting Operations with Wet Air Pollution Control
Devices
307.3403
Slag Processing
307.3404
Covered Calcium Carbide Furnaces With Wet Air Pollution Control Devices
307.3405
Other Calcium Carbide Furnaces
307.3406
Electrolytic Manganese Products
307.3407
Electrolytic Chromium
SUBPART Z: LEATHER TANNING AND FINISHING
10
Section
307.3500
General Provisions
307.3501
Hair Pulp, Chrome Tan, Retan-Wet Finish
307.3502
Hair Save, Chrome Tan, Retan-Wet Finish
307.3503
Hair Save or Pulp, Non-Chrome Tan, Retan-Wet Finish
307.3504
Retan-Wet Finish-Sides
307.3505
No Beamhouse
307.3506
Through-the-Blue
307.3507
Shearling
307.3508
Pigskin
307.3509
Retan-Wet Finish-Splits
307.3590
Potassium Ferricyanide Titration Method
SUBPART BA: GLASS MANUFACTURING
Section
307.3601
Insulation Fiberglass
307.3602
Sheet Glass Manufacturing
307.3603
Rolled Glass Manufacturing
307.3604
Plate Glass Manufacturing
307.3605
Float Glass Manufacturing
307.3606
Automotive Glass Tempering
307.3607
Automotive Glass Laminating
307.3608
Glass Container Manufacturing
307.3610
Glass Tubing (Danner) Manufacturing
307.3611
Television Picture Tube Envelope Manufacturing
307.3612
Incandescent Lamp Envelope Manufacturing
307.3613
Hand Pressed and Blown Glass Manufacturing
SUBPART BB: ASBESTOS MANUFACTURING
Section
307.3701
Asbestos-Cement Pipe
307.3702
Asbestos-Cement Sheet
307.3703
Asbestos Paper (Starch Binder)
307.3704
Asbestos Paper (Elastomeric Binder)
307.3705
Asbestos Millboard
307.3706
Asbestos Roofing
307.3707
Asbestos Floor Tile
307.3708
Coating or Finishing of Asbestos Textiles
307.3709
Solvent Recovery
307.3710
Vapor Absorption
307.3711
Wet Dust Collection
SUBPART BC: RUBBER MANUFACTURING
Section
307.3801
Tire and Inner Tube Plants
307.3802
Emulsion Crumb Rubber
307.3803
Solution Crumb Rubber
307.3804
Latex Rubber
307.3805
Small-Sized General Molded, Extruded and Fabricated Rubber Plants
307.3806
Medium-Sized General Molded, Extruded and Fabricated Rubber Plants
307.3807
Large-Sized General Molded, Extruded and Fabricated Rubber Plants
307.3808
Wet Digestion Reclaimed Rubber
307.3809
Pan, Dry Digestion and Mechanical Reclaimed Rubber
11
307.3810
Latex-Dipped, Latex-Extruded and Latex-Molded Rubber
307.3811
Latex Foam
SUBPART BD: TIMBER PRODUCTS PROCESSING
Section
307.3900
General Provisions
307.3901
Barking
307.3902
Veneer
307.3903
Plywood
307.3904
Dry Process Hardboard
307.3905
Wet Process Hardboard
307.3906
Wood Preserving-Water Borne or Nonpressure
307.3907
Wood Preserving-Steam
307.3908
Wood Preserving-Boulton
307.3909
Wet Storage
307.3910
Log Washing
307.3911
Sawmills and Planing Mills
307.3912
Finishing
307.3913
Particleboard Manufacturing
307.3914
Insulation Board
307.3915
Wood Furniture and Fixture Production Without Water Wash Spray Booth(s) or Without
Laundry Facilities
307.3916
Wood Furniture and Fixture Production with Water Wash Spray Booth(s) or With
Laundry Facilities
SUBPART BE: PULP, PAPER AND PAPERBOARD
Section
307.4000
General Provisions
307.4001
Dissolving Kraft
307.4002
Bleached Papergrade Kraft and Soda
307.4003
Unbleached Kraft
307.4004
Dissolving Sulfite
307.4005
Papergrade Sulfite
307.4006
Semi-Chemical
307.4007
Mechanical Pulp
307.4008
Non-Wood Chemical Pulp
307.4009
Secondary Fiber Deink
307.4010
Secondary Fiber Non-Deink
307.4011
Fine and Lightweight Papers from Purchased Pulp
307.4012
Tissue, Filter, Non-Woven, and Paperboard from Purchased Pulp
307.4013
Groundwood-Thermo-Mechanical (Repealed)
307.4014
Groundwood-CMN Papers (Repealed)
307.4015
Groundwood-Fine Papers (Repealed)
307.4016
Soda (Repealed)
307.4017
Deink (Repealed)
307.4018
Nonintegrated-Fine Papers (Repealed)
307.4019
Nonintegrated-Tissue Papers (Repealed)
307.4020
Tissue From Wastepaper (Repealed)
307.4021
Papergrade Sulfite (Drum Wash) (Repealed)
307.4022
Unbleached Kraft and Semi-Chemical (Repealed)
307.4023
Wastepaper-Molded Products (Repealed)
307.4024
Nonintegrated-Lightweight Papers (Repealed)
307.4025
Nonintegrated-Filter and Nonwoven Papers (Repealed)
12
307.4026
Nonintegrated-Paperboard (Repealed)
SUBPART BF: BUILDERS' PAPER AND BOARD MILLS (Repealed)
Section
307.4101
Builder's Paper and Roofing Felt (Repealed)
SUBPART BG: MEAT PRODUCTS
Section
307.4201
Simple Slaughterhouse
307.4202
Complex Slaughterhouse
307.4203
Low-Processing Packinghouse
307.4204
High-Processing Packinghouse
307.4205
Small Processor
307.4206
Meat Cutter
307.4207
Sausage and Luncheon Meats Processor
307.4208
Ham Processor
307.4209
Canned Meats Processor
307.4210
Renderer
SUBPART BH: METAL FINISHING
Section
307.4300
General Provisions
307.4301
Metal Finishing
SUBPART BN: PHARMACEUTICAL MANUFACTURING
Section
307.4900
General Provisions
307.4901
Fermentation Products
307.4902
Extraction Products
307.4903
Chemical Synthesis Products
307.4904
Mixing/Compounding and Formulation
307.4905
Research (Repealed)
SUBPART BR: PAVING AND ROOFING MATERIALS (TARS AND ASPHALT)
Section
307.5301
Asphalt Emulsion
307.5302
Asphalt Concrete
307.5303
Asphalt Roofing
307.5304
Linoleum and Printed Asphalt Felt
SUBPART BS: WASTE COMBUSTORS
Section
307.5401
Commercial Hazardous Waste Combustor
SUBPART BT: LANDFILLS
Section
307.5500
General Provisions
307.5501
RCRA Subtitle C Hazardous Waste Landfill
307.5502
RCRA Subtitle D Non-Hazardous Waste Landfill
SUBPART BU: PAINT FORMULATING
Section
307.5601
Oil-Base Solvent Wash Paint
13
SUBPART BV: INK FORMULATING
Section
307.5701
Oil-Base Solvent Wash Ink
SUBPART CD: PESTICIDE CHEMICALS
Section
307.6500
General Provisions
307.6501
Organic Pesticide Chemicals Manufacturing
307.6502
Metallo-Organic Pesticides Chemicals Manufacturing
307.6503
Pesticide Chemicals Formulating and Packaging
307.6505
Repackaging of Agricultural Pesticides Performed at Refilling Establishments
SUBPART CG: CARBON BLACK MANUFACTURING
Section
307.6801
Carbon Black Furnace Process
307.6802
Carbon Black Thermal Process
307.6803
Carbon Black Channel Process
307.6804
Carbon Black Lamp Process
SUBPART CJ: BATTERY MANUFACTURING
Section
307.7100
General Provisions
307.7101
Cadmium
307.7102
Calcium
307.7103
Lead
307.7104
Leclanche
307.7105
Lithium
307.7106
Magnesium
307.7107
Zinc
SUBPART CL: PLASTICS MOLDING AND FORMING
Section
307.7300
General Provisions
307.7301
Contact Cooling and Heating Water
307.7302
Cleaning Water
307.7303
Finishing Water
SUBPART CM: METAL MOLDING AND CASTING
Section
307.7400
General Provisions
307.7401
Aluminum Casting
307.7402
Copper Casting
307.7403
Ferrous Casting
307.7404
Zinc Casting
SUBPART CN: COIL COATING
Section
307.7500
General Provisions
307.7501
Steel Basis Material
307.7502
Galvanized Basis Material
307.7503
Aluminum Basis Material
14
307.7504
Canmaking
SUBPART CO: PORCELAIN ENAMELING
Section
307.7600
General Provisions
307.7601
Steel Basis Material
307.7602
Cast Iron Basis Material
307.7603
Aluminum Basis Material
307.7604
Copper Basis Material
SUBPART CP: ALUMINUM FORMING
Section
307.7700
General Provisions
307.7701
Rolling With Neat Oils
307.7702
Rolling With Emulsions
307.7703
Extrusion
307.7704
Forging
307.7705
Drawing With Neat Oils
307.7706
Drawing With Emulsions or Soaps
SUBPART CQ: COPPER FORMING
Section
307.7800
General Provisions
307.7801
Copper Forming
307.7802
Beryllium Copper Forming
SUBPART CR: ELECTRICAL AND ELECTRONIC COMPONENTS
Section
307.7901
Semiconductor
307.7902
Electronic Crystals
307.7903
Cathode Ray Tube
307.7904
Luminescent Materials
SUBPART CT: NONFERROUS METALS FORMING AND METAL POWDERS
Section
307.8100
General Provisions
307.8101
Lead-Tin-Bismuth Forming
307.8102
Magnesium Forming
307.8103
Nickel-Cobalt Forming
307.8104
Precious Metals Forming
307.8105
Refractory Metals Forming
307.8106
Titanium Forming
307.8107
Uranium Forming
307.8108
Zinc Forming
307.8109
Zirconium-Hafnium Forming
307.8110
Metal Powders
Appendix A
References to Previous Rules (Repealed)
AUTHORITY: Implementing Sections 7.2, 13, and 13.3 and authorized by Section 27 of the Environmental
Protection Act [415 ILCS 5/7.2, 13, 13.3, and 27].
15
SOURCE: Adopted in R70-5, at 1 PCB 426, March 31, 1971; amended in R71-14, at 4 PCB 3, March 7,
1972; amended in R74-3, at 19 PCB 182, October 30, 1975; amended in R74-15, 16, at 31 PCB 405, at 2 Ill.
Reg. 44, p. 151, effective November 2, 1978; amended in R76-17, at 31 PCB 713, at 2 Ill. Reg. 45, p. 101,
effective November 5, 1978; amended in R76-21, at 44 PCB 203, at 6 Ill. Reg. 563, effective December 24,
1981; codified at 6 Ill. Reg. 7818; amended in R82-5, 10, at 54 PCB 411, at 8 Ill. Reg. 1625, effective January
18, 1984; amended in R86-44 at 12 Ill. Reg. 2592, effective January 13, 1988; amended in R88-11 at 12 Ill.
Reg. 13094, effective July 29, 1988; amended in R88-18 at 13 Ill. Reg. 1794, effective January 31, 1989;
amended in R89-3 at 13 Ill. Reg. 19288, effective November 17, 1989; amended in R88-9 at 14 Ill. Reg. 3100,
effective February 20, 1990; amended in R89-12 at 14 Ill. Reg. 7620, effective May 8, 1990; amended in R91-
5 at 16 Ill. Reg. 7377, effective April 27, 1992; amended in R93-2 at 17 Ill. Reg. 19483, effective October 29,
1993; amended in R94-10 at 19 Ill. Reg. 9142, effective June 23, 1995; amended in R95-22 at 20 Ill. Reg.
5549, effective April 1, 1996; amended in R97-23 at 21 Ill. Reg. 11930, effective August 12, 1997; amended
in R99-4 at 23 Ill. Reg. 4413, effective March 31, 1999; amended in R99-17 at 23 Ill. Reg. 8421, effective July
12, 1999; amended in R00-15 at 24 Ill. Reg. 11640, effective July 24, 2000; amended in R01-5 at 25 Ill. Reg.
_______, effective _______________.
SUBPART A: GENERAL PROVISIONS
Section 310.107
Incorporations by Reference
a)
The following publications are incorporated by reference:
1)
The consent decree in NRDC v. Costle, 12 Environment Reporter Cases 1833
(D.C. Cir. August 16, 1978).
2)
Standard Industrial Classification Manual (1972), and 1977 Supplement,
republished in 1983, available from the Superintendent of Documents, U.S.
Government Printing Office, Washington, D.C. 20401.
b)
The following provisions of the Code of Federal Regulations are incorporated by
reference:
40 CFR 2.302 (1999)
40 CFR 25 (1999)
40 CFR 122, Appendix D, Tables II and III (1999)
40 CFR 128.140(b) (1977)
40 CFR 136 (1999), as amended at 64 Fed. Reg. 42552, August 4, 1999, and 64 Fed. Reg.
73414, December 30, 1999, and 65 Fed. Reg. 3008, January 19, 2000
40 CFR 403 (1999)
40 CFR 403, Appendix D (1999)
c)
The following federal statutes are incorporated by reference:
1)
Section 1001 of the Criminal Code (18 USC 1001) as of July 1, 1988
2)
Clean Water Act (33 USC 1251 et seq.) as of July 1, 1988
16
3)
Subtitles C and D of the Resource Conservation and Recovery Act (42 USC 6901
et seq.) as of July 1, 1988
d)
This Part incorporates no future editions or amendments.
(Source: Amended at 25 Ill. Reg. , effective .)
Section 307.1503 SeasonedCultured Products
a)
Applicability. This Section applies to discharges resulting from the
manufacture of cultured products, including cultured skim milk (cultured
buttermilk), yoghurt, sour cream and dips of various types.
b)
Specialized definitions. The Board incorporates by reference 40 CFR
405.31 (1994). This incorporation includes no later amendments or
editions.
c)
Existing sources:
1)
The Board incorporates by reference 40 CFR 405.34 (1994), at 60
Fed. Reg. 33926 effective June 29, 1995. This incorporation
includes no later amendments or editions.
2)
No person subject to the pretreatment standards incorporated by
reference in subsection (c)(1) shall cause, threaten or allow the
discharge of any contaminant to a POTW in violation of such
standards.
d)
New sources:
1)
The Board incorporates by reference 40 CFR 405.36 (1994), as
amended. at 60 Fed. Reg. 33926 effective June 29, 1995. This
incorporation includes no later amendments or editions.
2)
No person subject to the pretreatment standards incorporated by
reference in subsection (d)(1) shall cause, threaten or allow the
discharge of any contaminant to a POTW in violation of such
standards.
3)
"New source" means any building, structure, facility or installation
the construction of which commenced after December 20, 1973.
(Source: Amended at 25 Ill. Reg. , effective .)
SUBPART BS: WASTE COMBUSTORS
307.5401 Commercial Hazardous Waste Combustor
17
a) Applicability.
1) The Board incorporates by reference 40 CFR 444.10 (1999), as amended at 65
Fed. Reg. 4360, January 27, 2000. This incorporation includes no later
amendments or editions.
2) This Section applies to discharges of wastewater that are associated with
Commercial Hazardous Waste Combustor wastewater, as defined in the
materials incorporated by reference in Section 307.5401(a)(1).
b) Definitions. The Board incorporates by reference 40 CFR 444.11 (1999), as amended at 65
Fed. Reg. 4360, January 27, 2000. This incorporation includes no later amendments or
editions.
c) Monitoring requirements. The Board incorporates by reference 40 CFR 444.12 (1999), as
amended at 65 Fed. Reg. 4360, January 27, 2000 and 65 Fed. Reg. 33423, May 23, 2000.
This incorporation includes no later amendments or editions.
d) Existing sources:
1) The Board incorporates by reference 40 CFR 444.16 (1999), as amended at 65
Fed. Reg. 4360, January 27. This incorporation includes no later amendments or
editions.
2) No person subject to the pretreatment standards incorporated by reference in
Section 307.5401(d)(1) shall cause, threaten or allow the discharge of any
contaminant to a POTW in violation of such standards.
e) New sources:
1) The Board incorporates by reference 40 CFR 444.18 (1999), as amended at 65
Fed. Reg. 4360, January 27, 2000. This incorporation includes no later
amendments or editions.
2) No person subject to the pretreatment standards incorporated by reference in
Section 307.5401(e)(1) shall cause, threaten or allow the discharge of any
contaminant to a POTW in violation of such standards.
(Source: Added at 25 Ill. Reg. , effective .)
SUBPART BT: LANDFILLS
307.5500 General Provisions
a) Applicability.
1) The Board incorporates by reference 40 CFR 445.1 (1999), as amended at 65 Fed.
Reg. 3008, January 19, 2000. This incorporation includes no later amendments
or editions.
2) This Section applies to discharges of wastewater from landfill units, as defined in
the materials incorporated by reference in Section 307.5500(a)(1).
18
b) General definitions. The Board incorporates by reference 40 CFR 445.2 (1999), as
amended at 65 Fed. Reg. 3008, January 19, 2000. This incorporation includes no later
amendments or editions.
c) General Pretreatment Standards. The Board incorporates by reference 40 CFR 445.3
(1999), as amended at 65 Fed. Reg. 3008, January 19, 2000. This incorporation includes
no later amendments or editions.
(Source: Added at 25 Ill. Reg. , effective .)
307.5501 RCRA Subtitle C Hazardous Waste Landfill
a) Applicability. Except as provided in Section 307.5500, this Section applies to discharges
of wastewater from landfills subject to the provisions of 40 CFR Part 264, Standards for
Owners and Operators of Hazardous Waste Treatment, Storage, and Disposal Facilities,
Subpart N-(Landfills); and 40 CFR Part 265, Interim Status Standards for Owners and
Operators of Hazardous Waste Treatment, Storage, and Disposal Facilities, Subpart N-
(Landfills).
b) Existing sources:
1) The Board incorporates by reference 40 CFR 445.11 (1999), as amended at 65
Fed. Reg. 3008, January 19, 2000 and 65 Fed. Reg. 14344, March 16, 2000. This
incorporation includes no later amendments or editions.
2) No person subject to the pretreatment standards incorporated by reference in
Section 307.5501(b)(1) shall cause, threaten or allow the discharge of any
contaminant to a POTW in violation of such standards.
c) New sources:
1) The Board incorporates by reference 40 CFR 445.14 (1999), as amended at 65
Fed. Reg. 3008, January 19, 2000. This incorporation includes no later
amendments or editions.
2) No person subject to the pretreatment standards incorporated by reference in
Section 307.5501(c)(1) shall cause, threaten or allow the discharge of any
contaminant to a POTW in violation of such standards.
(Source: Added at 25 Ill. Reg. , effective .)
307.5502 RCRA Subtitle D Non-Hazardous Waste Landfill
a) Applicability. Except as provided in Section 307.5500, this Section applies to discharges
of wastewater from landfills subject to the provisions of 40 CFR Part 258, Criteria for
Municipal Solid Waste Landfills; and 40 CFR Part 257, Criteria for Classification of Solid
Waste Disposal Facilities and Practices.
b) Existing sources:
1) The Board incorporates by reference 40 CFR 445.21 (1999), as amended at 65
Fed. Reg. 3008, January 19, 2000 and 65 Fed. Reg. 14344, March 16, 2000. This
incorporation includes no later amendments or editions.
19
2) No person subject to the pretreatment standards incorporated by reference in
Section 307.5502(b)(1) shall cause, threaten or allow the discharge of any
contaminant to a POTW in violation of such standards.
c) New sources:
1) The Board incorporates by reference 40 CFR 445.24 (1999), as amended at 65
Fed. Reg. 3008, January 19, 2000. This incorporation includes no later
amendments or editions.
2) No person subject to the pretreatment standards incorporated by reference in
Section 307.5502(c)(1) shall cause, threaten or allow the discharge of any
contaminant to a POTW in violation of such standards.
(Source: Added at 25 Ill. Reg. , effective .)
IT IS SO ORDERED.
I, Dorothy M. Gunn, Clerk of the Illinois Pollution Control Board, hereby certify that the above
opinion and order was adopted on the 19th day of October 2000 by a vote of 7-0.
Dorothy M. Gunn, Clerk
Illinois Pollution Control Board
