ILLINOIS POLLUTION CONTROL BOARD
    April 7, 198S
    PRINTPACK, INC.,
    Petitioner,
    v.
    )
    PCB 87—189
    ILLINOIS ENVIRONMENTAL
    PROTECTION AGENCY,
    Respondent.
    ORDER OF THE BOARD (by Michael Nardulli):
    On April 1, 1988, the Petitioner, Printpack, Inc. and the
    Respondent, Illinois Environmental Protection Agency filed a
    Joint Motion to Modify the March 24, 1988 Order of the Board
    pursuant to 35 Ill. Adm. Code 103.240. The parties move the
    Board to modify one sentence of the Order to conform to the
    Agency’s amended variance recommendation. The sentence in
    question is the third sentence in paragraph 2 of the Board’s
    Order which should read as follows:
    “These quarterly reports shall include VOM
    emission data from the press department.”
    The changed words, which are underlined, replace the words “each
    printing press” in the Boar~s Order.
    The Motion to modify is granted. For clarity and
    administrative convenience, the corrected Board Order is
    reprinted in its entirety below.
    ORDER
    Petitioner, Printpack Packaging Corporation, is hereby
    granted variance from 35 Ill. Adm. Code 215.245 subject to the
    following conditions:
    1) The variance expires on March 31, 1989.
    2) During the term of this variance, Printpack shall
    submit quarterly written reports to the Agency
    detailing all progress made in achieving compliance
    with 35 Ill. ~dm. Code 215, Subpart P at its plant
    located at 1400 Abbott Drive, Elgin. The first
    quarterly report will be due thirty (30) days from
    the date of the Board order granting the variance.
    88—51
    —2—
    These quarterly reports shall include monthly VOM
    emission data from the press department. The first
    quarterly report shall also include copies of
    material data sheets showing the composition (in
    terms of percentage of solid, solvent and water) of
    all inks and coatings used during the flexographic
    and rotogravure printing processes. All of the
    above information shall be submitted to the Agency
    at the following address:
    A. Manager, Permit Section
    Division of Air Pollution Control
    Illinois Environmental Protection Agency
    1340 N. Ninth Street
    Springfield, Illinois 62702, and
    B. Manager, Field Operations Section
    Division of Air Pollution Control
    Illinois Environmental Protection Agency
    1701 S. First Avenue
    Suite 600
    Maywood, Illinois 60153
    3. No later than ninety (90) days prior to initiation
    of construction of a VOM control system, Printpack
    shall submit an application for a construction
    permit for that system in accordance with 35 Ill.
    Adm. Code 201.152. Construction shall not begin
    until a construction permit is issued. Operation of
    the emission control system is not allowed until an
    operating permit is issued by the Agency, pursuant
    to Section 35 Ill. Adm. Code 201.143.
    4. Printpack shall give thirty (30) days notice prior
    to the expected date of any stack test, to the
    Agency’s regional office and Emission Source
    Specialist at the address provided in Condition
    2.8. The Agency’s Emission Source Specialist shall
    be further notified a minimum of five (5) working
    days of the exact date, time and place of these
    tests, to enable the Agency to witness these tests.
    5. During the period of this variance VOM emissions
    from flexographic and rotogravure printing
    operations shall not increase more than 20 above
    projected 1987 levels.
    6. Within forty five (45) days after date of the Board
    Order, the Petitioner shall execute and send to:
    Mr. Joseph R. Podlewski, Jr.
    Enforcement Attorney
    Illinois Environmental Protection T~gency
    88—52
    —3—
    1701 S. First Avenue
    Suite 600
    Maywood, IL 60153
    A certification of its acceptance of this variance
    by which it agrees to be bound by its terms and
    conditions This forty—five (45) day period shall be
    held in abeyance for any period during which this
    matter is being appealed. If the Petitioner fails
    to execute and forward the agreement within a forty—
    five (45) day period, the variance shall be void.
    The form of the Certification shall be as follows:
    CERTIFICATION
    Printpack, Inc. hereby accepts and agrees to be bound by all
    terms and conditions of the Order of the Pollution Control Board
    in PCB 87—189 dated ________________________, 1988.
    Petitioner
    By: Authorized Agent
    Title
    Date
    Section 41 of the Environmental Protection Act, Ill. Rev.
    Stat. 1985 ch. 1111/2 par. 1041, provides for appeal of final
    Orders of the Board within 35 days. The Rules of the Supreme
    Court of Illinois establish filing requirements.
    IT IS SO ORDERED.
    I, Dorothy M. Gunn, Clerk of the Illinois Pollution Control
    Board, hereby certify that the above Order was adopted on
    the
    7~
    day of
    _____________________,
    1988, by a vote
    of
    7-o
    *
    17,.
    ~
    Dorothy M. G nn, Clerk
    Illinois Pollution Control Board
    88—53

    Back to top