ILLINOIS POLLUTION CONTROL BOARD

December 20, 1995

IN

THE MATTER OF:

)

R95—22

PRETREATMENT UPDATE

)

(Identical in Substance Rules-

(1/1/95

—

6/30/95)

)

Water)

PROPOSAL FOR PUBLIC COMMENT

PROPOSED OPINION AND ORDER OF THE BOARD (by E. Dunham):

The Board is amending the

pretreatment regulations pursuant

to Section 13.3 of the Environmental Protection Act

(

Act) (415

ILCS 5/13.3 (1994)).

Section 13.3 of the Act reguires the Board to adopt

regulations which are “identical in substance” with federal

regulations promulgated by the United States Environmental

Protection Agency (USEPA) to implement the pretreatment

requirements of Sections 307 and 402 of the Clean Water Act,

previously known as the Federal Water Pollution Control Act.

Section 13.3 provides that Title VII of the Act and Sections 5

and 6.02 of the Administrative Procedure Act (APA) shall not

apply to identical in substance regulations adopted to establish

the pretreatment program. However, Section 13.3 of the Act does

require the Board to provide for notice and public comment before

rules are filed with the Secretary of State.

This rulemaking updates the pretreatment rules to cover

USEPA rules adopted from January 1 through June 30, 1995. The

following Federal Registers are included:

60 Fed. Reg. 17160

April 4, 1995

60 Fed. Reg. 33926

June 29, 1995

The pretreatment rules govern discharges by industrial users

to publicly owned treatment works (POTWs). The rules are

intended to prevent pollutants from industrial discharges from

passing through POTWs, without adequate treatment, to waters of

the State, and to prevent industrial discharges from interfering

with the operation of the treatment plant. Effluent discharges

are regulated pursuant to 35 Iii. Adm. Code 304 and 309.

The Illinois pretreatment rules are contained in 35 Iii.

Adm. Code 307, 309 and 310. Part 307 includes the categorical

pretreatment standards, which are incorporated by reference from

the USEPA rules. Part 309 sets forth the NPDES requirements.

Although Part 309 does not pertain directly to sewer users and

industrial wastewater pretreatment, it includes requirements at

Section 309.103 that pertain to NPDES permittees- required to have

an approved pretreatment program. Part 310 specifies how a POTW

sets up a pretreatment program, and how industrial users get

pretreatment permits or authorizations to discharge.

---

2

PUBLIC COMMENTS

The Board proposes the amendments to 35 Ill. Adm. Code 307,

in this proposed opinion and order. The proposed amendments will

soon be published in the Illinois Register for public comment.

The public comment period will end 45 days after the date of

publication in the Illinois Register. The Board stresses the

importance that comluenters make their submissions promptly and

directly to the Clerk of the Board referencing Docket R95-22, so

the Board can obtain the benefit of the commenters input.

The discussion that follows indicates each topic on which

the Board especially invites public comment. In any event, the

Board construes silence as no objection to the Board’s approach

to each topic.

DISCUSSION

Update to Analytical Methods

The USEPA amended its guidelines for testing under the Clean

Water Act (40 CFR 136) to add clarifying notes and update

methods. Section 310.107 of the Illinois pretreatment

regulations incorporates 40 CFR 136. The Board updates the

incorporation of 40 CFR 136 in Section 310.107 to include the

amendments as adopted at 60 Fed. Reg. 17160.

Deletion of obsolete, redundant and outdated rules

The USEPA on June 29, 1995 at 60 Fed. Reg. 33926 deleted a

number of regulations that were obsolete or redundant. The rules

considered obsolete have expired by their own terms or by terms

of the statute or have been made obsolete by the completion of

the grant projects to which the regulation applied. The Board

today, updates the incorporations of the regulations of which

parts have been deleted by the USEPA. The USEPA noted that its

action did not make any legally substantive changes to the

regulatory program.

HISTORICAL OUTLINE OF BOARD PRETREATMENT REGULATION

The Illinois pretreatment rules were adopted in R86—44, 84

PCB 89, December 3, 1987. The rules appeared at 12 Ill. Reg.

2502 (January 29, 1988), effective January 13, 1988.

The Board has updated the pretreatment rules in the

following update rulemakings:

R88—11 90 PCB 411, June 14, 1988; 12 Ill. Reg. 13094,

effective July 29, 1988 (USEPA amendments through

December 31, 1987).

---

3

R88—18 94 PCB 237, December 17, 1988; 13 Iii. B.eg. 1794,

effective January 31, 1989 (USEPA amendments

January 1, 1988 through June 30,. 1988).

R89—3

103 PCB 609, September 28, 1989; 13 Ill. Reg.

19243, effective November 17, 1989 (Part 307) and

November 27, 1989 (Part 310) (USEPA amendments

July 1, 1988 through December 31, 1988).

R89—12 110 PCB 119, April 12, 1990; 14 Ill. Reg. 7608,

effective May 8, 1990 (USEPA amendments January 1,

1989 through June 30, 1989).

R90—6

Dismissed, 109 PCB 629, March 22,

1990 (No TJSEPA

amendments July 1, 1989 through December 31,

1989).

R90—15 Dismissed, June 20, 1991 (No USEPA amendments

January 1 1990 through June 28, 1990).

R91—5

129 PCB 395, January 23, 1992; 16 Ill. Reg. 7377

(Part 307); 7337 (Part 309); 7346 (Part 310);

effective April 27, 1992. (USEPA amendments June

29, 1990 through December 31, 1990).

R91—17 Dismissed, December 6, 1991 (No USEPA amendments

January 1, 1991 through June 30, 1991).

R92-5

Dismissed, April 9, 1992

(No

USEPA amendments July

1, 1991 through December 31, 1991).

R92—14 Dismissed, August 13, 1992 (No USEPA amendments

January 1, 1992 through June 30, 1992).

R93—2

____PCB_____ September 9, 1993, 17 111. Reg. 19483

effective October 29, 1993 (USEPA amendments July

1, 1992 through December 31, 1992).

R93—20 Dismissed April 9, 1992 (No USEPA amendments

January 1, 1993 through June 30, 1993).

R94—1O ____PCB_____ May 18, 1995, 19 Ill. Reg. 9142

effective June 23, 1995 (USEPA amendments July 1,

1993 through December 31, 1993).

R94—28 Dismissed October 6, 1994 (No USEPA amendments

January 1, 1994 through June 30, 1994).

R95—8

Dismissed February 16, 1994 (USEPA amendments July

1, 1994 through December 31, 1994).

R95-22 This docket.

---

4

TITLE 35: ENVIRONMENTAL PROTECTION

SUBTITLE C: WATER POLLUTION

CHAPTER I: POLLUTION CONTROL BOARD

PART 307

SEWER DISCHARGE CRITERIA

SUBPART F: DAIRY PRODUCTS PROCESSING

Section 307.1502 Fluid Products

a) Applicability. This Section applies to discharges

resulting from the manufacture of market milk (ranging

For mailing purposes, the Board has omitted the tables of

contents from the order since no changes are proposed to be made in

the table of contents. Interested persons may view the tables of

ôontents in its entirety in the copy of the proposal submitted by

the Agency and retained in the Clerk’s file. An entire version

including the full tables of contents will be published in the

Illinois Register, and a copy of that submittal is available in the

Clerk’s file.

ORDER’

The Board hereby proposes

the following amendments to the

Illinois wastewater treatment regulations at Sections 307.1502,

307.1503, 307.1504, 307.1505, 307.1506, 307.1507, 307.1508,

307.1509, 307.1510, 307.1511,

307.1512, 107.1601, 307.1602,

307.1603, 307.1504,

307.1605, 307.1606, 307.1607, 307.1608,

307.1609,

307.1610, 307.1702, 307.1703, 307.1704, 307.1705,

307.1706, 307.1707, 307.1708, 307.1801, 307.1815, 307.1901,

307.1902, 307.1903, 307.2101, 307.2103, 307.2201, 307.2701,

307.2702, 307.2703,

307.2704, 307.2705, 307.2706, 307.2707,

307.2708, 307.2709, 307.2710, 307.2711, 307.2712, 307.2713,

307.2714, 307.2715, 307.2716, 307.2717, 307.2718, 307.2719,

307.3401, 307.3402, 307.3403, 307.3601, 307.3602, 307.3603,

307.3604,

307.3605, 307.3606, 307.3607, 307.3607, 307.3608,

307.3610, 307.3611, 307.3612, 307.3613, 307.3701, 307.3702,

307.3703, 307.3704, 307.3705,

307.3706, 307.3707, 307.3708,

307.3709,

307.3710, 307.3711, 307.3801, 307.3804, 307.3805,

307.3806,

307.3807, 307.3808, 307.3809, 307.3810, 307.3811,

307.4201, 307.4202,

307.4203, 307.4204, 307.4205, 307.4206,

307.4207, 307.4208, 307.4209, 307.4210, 307.5301, 307.5302,

307.5303, 307.5304, 307.5601, 307.5701, 307.6801, 307.6802,

307.6803, 307.6804, 309.103,

310.103,

310.107,

310.510,

310.602,

310.711,

310.910,

310.911,

310.912,

310.913.

---

5

from 3.5 fat to fat-free), flavored milk (chocolate

and others) and cream (of various fat concentrations,

plain and whipped).

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.21 (19S4~j). This incorporation

includes no later amendments or editions.

C)

Existing sources:

1) The Board incorporates by reference 40 CFR 405.24

(19~4~j),as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 405.26

(19&694),

as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

Ill. Req.

________,

effective

Section 307.1503 Seasoned Products

a) Applicability. This Section applies to discharges

resulting from the manufacture of cultured products,

including cultured skim milk (cultured buttermilk),

yogurt, sour cream and dips of various types.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.31 (198-6~j). This incorporation

includes no later amendments or editions.

---

6

C)

Existing sources:

1) The Board incorporates by reference 40 CFR 405.34

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 405.36

(19S494). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

Section 307.1504 Butter

a) Applicability. This Section applies to discharges

resulting from the manufacture of butter, either by

churning or continuous process.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.41 (19&6~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 405.44

(198-G~j)~asamended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

7

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 405.46

(19~694), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

Ill. Reg.

_________

effective

Section 307.1505 Cottage Cheese and Cultured Cream Cheese

a) Applicability. This Section applies to discharges

resulting from the manufacture of cottage cheese and

cultured cream cheese.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.51 (l9&6~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 405.54

(198-6-94), as amended at 60 Fed. Req. 33926

effective June 29, 1995). This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

8

d) New sources:

1) The Board incorporates by reference 40 CFR 405.56

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

______

Ill. Reg.

________,

effective

Section 307.1506 Natural and Processed Cheese

a) Applicability. This Section applies to discharges

resulting from the manufacture of natural cheese (hard

curd) and processed cheese.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.61 (19&6~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 405.64

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 405.66

(1984~j),as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

---

9

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

______

Ill. Reg.

_________

effective

______________________________________________________________ )

Section 307.1507 Fluid Mix for Ice Cream and other Frozen

Desserts

a) Applicability. This Section applies to discharges

resulting from the manufacture of fluid mixes for ice

cream and other frozen desserts for later freezing in

other plants; it does not include freezing of the

products as one of the affected operations.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.71 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 405.74

(19-8494)~ as amended at 60 Fed. Reqi. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POPW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 405.76

(199-694),, as amended at 60 Fed. Req. 33926

effective June 29, 199~. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

10

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

______

Ill. Reg.

________,

effective

______________________________________________________________ )

Section 307.1508 Ice Cream, Frozen Desserts, Novelties and

Other Dairy Desserts

a) Applicability. This Section applies to discharges

resulting from the manufacture of ice cream, ice milk,

sherbet, water ices, stick confections, frozen

novelties products, frozen desserts, melorine, pudding

and other dairy product base desserts. If fluid mixes

prepared at another plant are employed, the appropriate

values from Section 307.1507 should be deducted from

the limitations.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.81 (19S~7-~j)). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 405.84

(l98-7~94), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (c) (1)

shall cause, threaten or allow the discharge of

any contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 405.86

(198-~94), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (d) (1)

shall cause, threaten or allow the discharge of

any contaminant to a POTW in violation of such

standards.

---

11

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at ______Ill. Reg.

_________,

effective

______________________________________________________________ )

Section 307.1509 Condensed Milk

a) Applicability. This Section applies to discharges

resulting from the manufacture of condensed whole milk,

condensed skim milk, sweetened condensed milk and

condensed butter milk.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.91 (19&6~4~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 405.94

(19.8-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 405.96

(198-6-94), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

Ill, Reg.

_________,

effective

________________________________________________ )

---

12

Section 307.1510 Dry Milk

a) Applicability. This Section applies to discharges

resulting from the manufacture of dry whole milk, dry

skim milk and dry buttermilk.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.101 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 405.104

(1984~).

This incorporation

includes no later

amendments or editions.

2)

No person subject to the pretreatment

standards

incorporated by reference in subsection (1)

shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 405.106

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

Ill. Reg.

________,

effective

Section 307.1511 Condensed Whey

a) Applicability. This Section applies to discharges

resulting from the manufacture of condensed sweet whey

and condensed acid whey.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.111 (1984~). This incorporation

includes no later amendments or editions.

---

13

c) Existing sources:

1) The Board incorporates by reference 40 CFR 405.114

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 405.116

(198-694), as amended at 60 Fed. Rec~. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

_______________________________________________ )

Section 307.1512 Dry Whey

a) Applicability. This Section applies to discharges

resulting from the manufacture of sweet or acid dry

whey.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 405.121 (l984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 405.124

(19~~j)~asamended at 60 Fed. Re~cL 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

---

14

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d)

New sources:

1) The Board incorporates by reference 40 CFR 405.126

(198-694)~asamended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 20, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

________________________________________________ )

SUBPART G: GRAIN MILLS

Section 307.1601 Corn Wet Milling

a) Applicability. This Section applies to discharges

resulting from the process in which shelled corn is

steeped in a dilute solution of sufurous acid and then

processed by wet means into such products as animal

feed, regular and modified starches, corn oil, corn

syrup and dextrose.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.11 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 406.14

(19-8494), as amended at 60 Fed. Reg. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

15

d) New sources:

1) The Board incorporates by reference 40 CFR 406.16

(198-6~).as amended at 60 Fed. Reg. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 4, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

________________________________________________ )

Section 307.1602 Corn Dry Milling

a) Applicability. This Section applies to discharges

resulting from the process in which shelled corn is

washed and subsequently milled by dry processes into

such products as corn meal, grits, flour, oil and

animal feed. This Section does not apply to discharges

from subsequent manufacturing operations to produce

expanded or extruded feed or feed products.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.21 (198-694), as amended at 60 Fed.

Req. 33926 effective June 29, 1995. This incorporation

includes no later amendments or editions.

C)

Existing sources:

1) The Board incorporates by reference 40 CFR 406.24

(1984~). This incorporation includes no later

amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

16

d) New sources:

1) The Board incorporates by reference 40 CFR 406.26

(1984~)~asamended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 4, 1973.

(Source: Amended at

Ill. Reg.

effective

________________________________________________ )

Section 307.1603 Normal Wheat Flour Milling

a) Applicability. This Section applies to discharges

resulting from the processes in which wheat and other

grains are milled by dry processes into flour and

millfeed.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.31 (198-6.~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 406.34

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 406.36

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

17

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 4, 1973.

(Source: Amended at

Ill. Reg.

________,

effective

____________________________________________)

Section 307.1604 Bulgur Wheat Flour Milling

a) Applicability. This Section applies to discharges

resulting from the process in which wheat is parboiled,

dried and partially debranned in the production of

bulgur.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.41 (1984~4). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 406.44

(198494), as amended at 6~1Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d)

New sources:

1) The Board incorporates by reference 40 CFR 406.46

(19&6,~4j. as amended at 60 Fed. Req.~33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

18

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 4, 1973.

(Source: Amended at

Ill. Reg.

________,

effective

________________________________________________ )

Section 307.1605 Normal Rice Milling

a) Applicability. This Section applies to discharges

resulting from the process in which rice is cleaned and

milled by dry processes.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.51 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 406.54

(l9&6~4j,as amended at 60 Fed. Reg. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 406.56

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTw in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 4, 1973.

(Source: Amended at______ Ill. Reg.

__________

effective

---

19

Section 307.1606 Parboiled Rice Milling

a) Applicability. This Section applies to discharges

resulting from the process in which rice is cleaned,

cooked and dried before being milled.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.61 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 406.64

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 406.66

(1984~). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 4, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

Section 307.1607 Animal Feed

a) Applicability. This Section applies to discharges

resulting from the manufacturing of animal feeds

(formula feed concentrate) using primarily grain and

grain by-products which may be supplemented by

proteins, pharmaceuticals, vitamins or mineral

additives.

---

20

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.71 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources:, These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 406.76

(1984~).as amended at 60 Fed. Reg. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after September 17, 1974.

(Source: Amended at

Ill. Req.

________,

effective

Section 307.1608 Hot Cereal

a) Applicability. This Section applies to discharges

resulting from the production of various breakfast

cereals from grains, principally wheat and oats,

requiring cooking prior to normal human consumption.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.81 (198-6.~j). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 406.86

(198-694). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

21

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after September 17, 1974.

(Source: Amended at

Ill. Reg.

________,

effective

____________________________________________

)

Section 307.1609 Ready-to-eat Cereal

a) Applicability. This Section applies to discharges

resulting from the processing of various grains and

other materials (whole grain wheat, rice, corn grits,

oat flour, sugar and minor ingredients) to produce

various breakfast cereals normally available for human

consumption without cooking.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.91 (19842j). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 406.96

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after September 17, 1974.

(Source: Amended at

Ill. Reg.

_________

effective

---

22

Section 307.1610 Wheat Starch and Gluten

a) Applicability. This Section applies to discharges

resulting from those industrial operations utilizing

wheat flour as a raw material for production of wheat

starch and gluten (protein) components through

conventional processes of physical separation and

subsequent refinement.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 406.101 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 406.106

(1984~),as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after September 17, 1974.

(Source: Amended at

Ill. Reg.

_________,

effective

________________________________________________ )

SUBPART H: CANNED AND PRESERVED FRUITS AND VEGETABLES

Section 307.1701 Apple Juice

a) Applicability. This Section applies to discharges

resulting from the processing of apples into apple

juice or apple cider.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 407.11 (1984~j). This incorporation

includes no later amendments or editions.

---

23

c) Existing sources:

1) The Board incorporates by reference 40 CFR 407.14

(l984~)~as amended at 60 Fed. Req. 3392k

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 407.16

(19~8.694)~as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3)

“New source” means any building,

structure,

facility or

installation

the construction of which

commenced after November 9, 1974.

(Source: Amended at

Ill. Reg.

_________,

effective

Section 307.1702 Apple Products

a) Applicability. This Section applies to discharges

resulting from the processing of apples into apple

products. The processing of apples into caustic peeled

or dehydrated products is specifically excluded,

b) Specialized definitions. The Board incorporates by

reference 40 CFR 407.21 (l9.84~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 407.24

(1984~). as amended at 60 Fed. Req. 33926

effective June 29~ 1995. This incorporation

includes no later amendments or editions.

---

24

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 407.26

(1984~)~as amended at 60 Fed. Reg. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after November 9, 1974.

(Source: Amended at

Ill. Req.

effective

________________________________________________)

Section 307.1703 Citrus Products

a) Applicability. This Section applies to discharges

resulting from the processing of citrus into citrus

products.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 407.31 (l984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 407.34

(19-84~j). This incorporation includes no later

amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

25

d)

New sources:

1) The Board incorporates by reference 40 CFR 407.36

(198494). as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after November 9, 1974.

(Source: Amended at

Ill. Reg.

________,

effective

________________________________________________)

Section 307.1704 Frozen Potato Products

a) Applicability. This Section applies to discharges

resulting from the processing of white potatoes into

frozen potato products.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 407.41 (198-3~). This incorporation

includes no later amendments or editions.

C)

Existing sources:

1) The Board incorporates by reference 40 CFR 407.44

(198-~7-94), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (c) (1)

shall cause, threaten or allow the discharge of

any contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 407.46

(198-7-~4j.~as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

26

2) No person subject to the pretreatment standards

incorporated by reference in subsection (d) (1)

shall cause, threaten or allow the discharge of

any contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after November 9, 1974.

(Source: Amended at

______

Ill. Reg.

_________,

effective

____________

)

Section 307.1705 Dehydrated Potato Products

a) Applicability. This Section applies to discharges

resulting from the processing of white potatoes into

dehydrated potato products.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 407.51 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 407.54

(198-&~).as amended at 60 Fed. Req.

3.~926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 407.56

(198494)~as amended at 60 Fed. Req. 3~926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

27

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after November 9, 1974.

(Source: Amended at

______

Ill. Reg.

- ,

effective

_________________________________________)

Section 307.1706 Canned and Preserved Fruits

a) Applicability. This Section applies to discharges

resulting from the processing of the following fruit

products: apricots; caneberries; sweet, sour and

brined cherries; cranberries; dried fruit; grape juice

canning and pressing; olives; peaches; pears; fresh and

processed pickles, and pickle salting stations;

pineapples; plums; raisins; strawberries; and tomatoes.

b) Specialized definitions. The Board Incorporates by

reference 40 CFR 407.61 (19S-6~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 407.64.

(l984~),as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 407.66

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

28

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 21, 1975.

(Source: Amended at

______

Ill. Reg.

_________,

effective

________________________________________)

Section 307.1707 Canned and Preserved Vegetables

a) Applicability. This Section applies to discharges

resulting from the processing of the following

vegetable products: beets; broccoli; carrots; canned

and frozen corn; dehydrated onions and garlic;

dehydrated vegetables; dry beans; lima beans;

mushrooms; canned onions; peas; sauerkraut canning and

cutting; snap beans; spinach; squash; and canned

potatoes.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 407.71 (198-6~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 407.74

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci)

New sources:

1) The Board incorporates by reference 40 CFR 407.76

(198-694)~s amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2)

No person subject to the pretreatment

standards

incorporated

by reference in subsection

(1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

29

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 21, 1975.

(Source: Amended at

______

Ill. Reg.

________,

effective

__________________________________________________ )

Section 307.1708 Canned and Miscellaneous Specialties

a) Applicability. This Section applies to discharges

resulting from the processing of the following

specialty products: added ingredients; baby food;

corn, potato and tortilla chips; ethnic foods; jams and

jellies; mayonnaise and dressings; soups; and tomato—

starch—cheese canned specialties.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 407.81 (1984li). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 407.84

(l984~). as amended at 60 Fed. Reg. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 407.86

(198-6~j),as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 21, 1975.

(Source: Amended at

______,

Ill. Reg.

________,

effective

)

---

30

SUBPART I: CANNED AND PRESERVED SEAFOOD

Section 307.1801 Farm—raised Catfish

a) Applicability. This Section applies to discharges

resulting from the processing of farm-raised catfish by

existing facilities which process more than 1362 kg

(3000 lbs) of raw material per day on any day during a

calendar year and all new sources.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 408.11 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 408.14

(l984~), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 408.16

(198-6-94), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after February 6, 1974.

(Source: Amended at

Ill. Reg.

________,

effective

Section 307.1815 Fish Meal Processing Subcategory

a) Applicability. This Section applies to discharges

resulting from the processing of menhaden on the Gulf

---

31

and Atlantic Coasts and the processing of anchovy on

the West Coast into fish meal, oil and solubles.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 408.151 (1984.~.j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 408.154

(198494)~as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 408.156

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after January 30, 1975.

(Source: Amended at

Ill. Reg.

_________,

effective

______________________________________________ )

SUBPART J: SUGAR PROCESSING

Section 307.1901 Beet Sugar Processing

a) Applicability. This Section applies to discharges

resulting from any operation attendant to the

processing of sugar beets for the production of sugar.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 409.11 (1984~). This incorporation

includes no later amendments or editions.

---

32

c) Existing sources:

1) The Board incorporates by reference 40 CFR 409.14

(1984~j),as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 409.16

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 22, 1973.

(Source: Amended at

Ill. Reg.

__________,

effective

______________________________________________)

Section 307.1902 Crystalline Cane Sugar Refining

a) Applicability. This Section applies to discharges

resulting from the processing of raw cane sugar into

crystalline refined sugar.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 409.21 (l984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 409.24

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

---

33

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 409.26

(198-6~4j, as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 7, 1973.

(Source: Amended at

Ill. Reg.

__________,

effective

______________________________________________ )

Section 307.1903 Liquid Cane Sugar Refining

a) Applicability. This Section applies to discharges

resulting from the processing of raw cane sugar into

liquid refined sugar.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 409.31 (l98-6~4j. This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 409.34

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 409.36

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

---

34

includes no later amendments or editions.

2)

No person subject to the pretreatment

standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 7, 1973.

(Source: Amended at

______,

Ill. Reg.

________,

effective

_______________________________ )

SUBPART L: CEMENT MANUFACTURING

Section 307.2101 Nonleaching

a) Applicability. This Section applies to discharges

resulting from the process in which several mineral

ingredients (limestone or other natural sources of

calcium carbonate, silica, alumina, and iron together

with gypsum) are used in the manufacturing of cement

and in which kiln dust is not contracted with water as

an integral part of the process and water is not used

in wet scrubbers to control kiln stack emissions.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 411.11 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 411.14

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 411.16

(1984~). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

35

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after September 7, 1973.

(Source: Amended at

_____

Ill. Reg.

__________,

effective

____________________________________________)

Section 307.2102 Leaching

a) Applicability. This Section applies to discharges

resulting from the process in which several mineral

ingredients (limestone or other natural sources of

calcium carbonate, silica, alumina, and iron together

with gypsum) are used in the manufacturing of cement

and in which kiln dust is contacted with water as an

integral part of the process or water is used in wet

scrubbers to control kiln stack emissions.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 411.21 (l9&~~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 411.24

(198-7-n). This incorporation includes no later

amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (c) (1)

shall cause, threaten or allow the discharge of

any contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 411.26

(19~8-7-94). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (ci) (1)

shall cause, threaten or allow the discharge of

any contaminant to a POTW in violation of such

standards.

---

36

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after September 7, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

Section 307.2103 Materials Storage Piles Runoff

a) Applicability. This Section applies to discharges

resulting from the runoff of rainfall which derives

from the storage of materials including raw materials,

intermediate products, finished products and waste

materials which are used in or derived from the

manufacture of cement under either Section 307.2101 or

307.2102

b) Specialized definitions. The Board incorporates by

reference 40 CFR 411.31 (l984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 411.34

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 411.36

(1984~).as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

37

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after September 7, 1973.

(Source: Amended at

Ill. Req.

_________,

effective

SUBPART M: FEEDLOTS

Section 307.2201 General

a) Applicability. This Section applies to discharges

resulting from feedlots in the following subcategories:

Beef cattle

--

open lots; beef cattle

—-

housed lots;

dairy cattle

--

stall barn (with milk room); dairy

—-

free stall barn (with milking center); dairy

-—

cowyards (with milking center); swine

--

open dirt or

pasture lots; swine

——

housed, slotted floor; swine

-—

solid concrete floor, open or housed lot; sheep

——

open

lots; sheep

——

housed lots; horses

-—

stables (race

tracks); chickens

——

broilers, housed; chickens

——

layers (egg production), housed; chickens

—~

layer

breeding or replacement stock; housed; turkeys

——

open

lots; turkeys

--

housed; and for those feedlot

operations within these subcategories as large or

larger than the capacities given below: 1,000

slaughter steers and heifers; 700 mature dairy cattle

(whether milkers or dry cows); 2,500 swine weighing

over 55 pounds; 10,000 sheep; 55,000 turkeys, 100,000

laying hens or broilers when facility has unlimited

continuous flow watering systems; 30,000 laying hens or

broilers when facility has liquid manure handling

system; 500 horses; and 1,000 animal units from a

combination of slaughter steers and heifers, mature

dairy cattle, swine over 55 pounds and sheep.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 412.11 (l984~4j. This incorporation

includes no later amendments or editions.

C)

Existing sources:

1) The Board incorporates by reference 40 CFR 412.14

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

38

2)

No person subj ect to the pretreatment

standards

incorporated

by reference in subsection

(1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 412.16

(1984j4~)1as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after September 7, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

SUBPART R: SOAP AND DETERGENTS

Section 307.2701 soap Manufacturing by Batch Kettle

a) Applicability. This Section applies to discharges

resulting from operations in which neat soap is

produced through saponification of animal and vegetable

fats and oils by boiling in kettles.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.11 (l9&6~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.14

(198-694). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

39

d) New sources:

1) The Board incorporates by reference 40 CFR 417.16

(1984~), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

—,

Ill. Reg.

________,

effective

________________________________________________)

Section 307.2702 Fatty Acid Manufacturing by Fat Splitting

a) Applicability. This Section applies to discharges

resulting from the splitting of fats to fatty acids by

hydrolysis and the subsequent processing of the fatty

acids (e.g., refining and hydrogenation) to produce a

suitable feed material for manufacture of soap by fatty

acid neutralization.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.21 (l984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.24

(19-8494), as amended at 60 Fed. Req. 33926

effective June 29,1 995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.26

(198494), as at 60 Fed. Req. 33926 effective June

29, 1995. This incorporation includes no later

amendments or editions.

---

40

2)

No person

subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

____________________________________________)

Section 307.2703 Soap Manufacturing by Fatty Acid

Neutralization

a) Applicability. This Section applies to discharges

resulting from the manufacturing of neat soap by

neutralizing refined fatty acids with an alkaline

material in approximately stoichiemetric amounts in

batch or continuous operations.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.31 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.34

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.36

(198494), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

41

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

______,

Ill. Req.

_________,

effective

___________________________________________ )

Section 307.2704 Glycerine Concentration

a) Applicability. This Section applies to discharges

resulting from the concentration of sweet water from

saponification or fat splitting to approximately 60 to

80 percent crude glycerine content.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.41 (19&6~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.44

(1984~j).as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.46

(1984~). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Req.

_________,

effective

)

---

42

Section 307.2705 Glycerine Distillation

a) Applicability. This Section applies to discharges

resulting from the production of finished glycerine of

various grades (e.g., USP) through concentration from

crude glycerine by means of distillation.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.51 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.54

(1984~j).as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.56

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

Section 307.2706 Manufacture of Soap Flakes and Powders

a) Applicability. This Section applies to discharges

resulting from all operations associated with the

manufacture of soap flakes and powders, commencing with

the drying of the neat soap to and including packaging

of the finished flakes and powders.

---

43

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.61 (l984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.64

(1984~), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.66

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

____________________________________________)

Section 307.2707 Manufacture of Bar Soaps

a) Applicability. This Section applies to discharges

resulting from all operations associated with

conversion of neat soap to finished bar soaps,

including drying, milling, plodding, stamping and

packaging.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.71 (1984~), This incorporation

includes no later amendments or editions.

---

44

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.74

(1984~), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 417.76

(l98-694)~ as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

______

Ill. Reg.

,

effective

__________________________________________________ )

Section 307.2708 Manufacture of Liquid Soaps

a) Applicability. This Section applies to discharges

resulting from the blending of ingredients employed in

the manufacture of liquid soaps and the packaging of

the finished products.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.81 (l98-&~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.84

(l984~), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

45

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.86

(198-694), as amended at 60 Fed. Req. 33926

effective June 29~, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Reg.

__________,

effective

________________________________________________ )

Section 307.2709 Oleum Sulfonation and Sulfation

a) Applicability. This Section applies to discharges

resulting from the manufacture of sulfonic acid and

sulfuric acid esters by means of sulfonation and

sulfation of raw materials, including but not limited

to petroleum derived alkyls, employing oleum in either

continuous or batch processes.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.91 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.94

(198-6~j). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

46

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.96

(198-694). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

______

Ill. Reg.

_________,

effective

Section 307.2710 Air-Sulfur Trioxide Sulfation and Sulfonation

a) Applicability. This Section applies to discharges

resulting from the manufacture of sulfonic acid and

sulfuric acid esters by means of sulfation and

sulfonation employing air and sulfur trioxide in either

continuous or batch processes.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.101 (1984~.j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.104

(19&69j), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.106

(1984~), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

47

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

______

Ill. Reg.

________,

effective

Section 307.2711 Sulfur Trioxide Solvent and Vacuum

Sulfonation

a) Applicability. This Section applies to discharges

resulting from the operations in which undiluted sulfur

trioxide and organic reactant are fed through a mixing

nozzle into a vacuum reactor where the sulfonation of

the organic reactant takes place.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.111 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.114

(1984~), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 417.116

(l98-6~j), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

48

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

______

Ill. Reg.

_________,

effective

_________________________________________________

)

Section 307.2712 Sulfamic Acid Sulfation

a) Applicability. This Section applies to discharges

resulting from operations in which sulfamic acid is

employed as the sulfating agent.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.121 (l9&6~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.124

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 417.126

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Reg.

____________________

effective

---

49

Section 307.2713 Chiorosulfonic Acid Sulfation

a) Applicability. This Section applies to discharges

resulting from sulfation of alcohols, alkyiphenols

and

alcohol ethoxylates utilizing chiorosulfonic acid as

the sulfating agent.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.131 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.134

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.136

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Reg.

,

effective

Section 307.2714 Neutralization of Sulfuric Acid Esters and

Sulfonic Acids

a) Applicability. This Section applies to discharges

resulting from the continuous or batch neutralization

of sulfated and sulfonated alkylbenzenes, alcohols and

other materials to convert them to neutral salts.

---

50

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.141 (198494). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 417.144

(1984~j)~asamended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.146

(19842j)~as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Req.

________,

effective

___________________________________________________

)

Section 307.2715 Manufacture of Spray Dried Detergents

a) Applicability. This Section applies to discharges

resulting from all operations associated with the

manufacture of spray dried detergents, including but

not limited to assembly and storage of raw materials,

crutching, spray drying, blending (including tumble

spraying or additives) and packaging.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.151 (1984~). This incorporation

includes no later amendments or editions.

---

51

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.156

(l984~). as amende&at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

______

Ill. Reg.

__________,

effective

____________)

Section 307.2716 Manufacture of Liquid Detergents

a) Applicability. This Section applies to discharges

resulting from all operations associated with the

manufacture of liquid detergents, commencing with the

blending of ingredients, to and including bottling or

packaging finished products.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.161 (19849j). This incorporation

includes no later amendments or editions.

C)

Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.166

(19’8414J, as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

52

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Reg.

__________,

effective

Section 307.2717 Manufacturing of Detergents by Dry Blending

a) Applicability. This Section applies to discharges

resulting from operations associated with the

manufacture of detergents by means of the blending of

dry ingredients, including, but not limited to,

blending and subsequent packaging.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.171 (l984~j). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.176

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

______

Ill. Reg.

________,

effective

Section 307.2718 Manufacture of Drum Dried Detergents

a) Applicability. This Section applies to discharges

resulting from operations associated with the

manufacture of detergents by drum drying, including,

but not limited to, drying of formulations on heated

drums or rollers, conversion of dried detergents to

powders or flakes and packaging of finished products.

---

53

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.181 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.186

(198494),

as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Req.

________,

effective

_______________________________________)

Section 307.2719 Manufacture of Detergent Bars and Cakes

a) Applicability. This Section applies to discharges

resulting from operations associated with the

manufacture of detergent bars and cakes, including, but

not limited to, drying, milling, plodding, stamping and

packaging.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 417.191 (1984~). This incorporation

includes no later amendments or editions.

C)

Existing sources:

1) The Board incorporates by reference 40

CFR

417.194

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

54

ci) New sources:

1) The Board incorporates by reference 40 CFR 417.196

(19&69j), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 26, 1973.

(Source: Amended at

Ill. Req.

,

effective

_________________________________________)

SUBPART Y: FERROALLOY MANUFACTURING

Section 307.3401 Open Electric Furnaces With Wet Air Pollution

Control Devices

a) Applicability. This Section applies to discharges

resulting from the smelting of ferroalloys in open

electric furnaces with wet air pollution control

devices. This subcategory includes those electric

furnaces of such construction or configuration that the

furnace off—gases are burned above the furnace charge

level by air drawn into the system. After combustion

the gases are cleaned in a wet air pollution control

device, such as a scrubber, an electrostatic

precipitator

with water or other aqueous sprays, etc.

The provisions of the Section are not applicable to

noncontact cooling water or to those electric furnaces

which are covered, closed, sealed or semi—covered and

in which the furnace off-gases are not burned prior to

collection (regulated in Section 301.3402).

b) Specialized definitions. The Board incorporates by

reference 40 CFR 424.11 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

---

55

ci)

New sources:

1) The Board incorporates by reference 40 CFR 424.1~

(l984~)~as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 18, 1973.

(Source: Amended at

______

Ill. Reg.

_________,

effective

_____________________________________________________ )

Section 307.3402 Covered Electric Furnaces and Other Smelting

Operations with Wet Air Pollution Control

Devices

a) Applicability. This Section applies to discharges

resulting from the smelting of ferroalloys in covered

electric furnaces or other smelting operations, not

elsewhere included in this Subpart, with wet air

pollution control devices. This subcategory includes

those electric furnaces of such construction or

configuration (known as covered, closed, sealed, semi-

covered or semi—closed furnaces) that the furnace off—

gases are not burned prior to collection and cleaning,

and which off—gases are cleaned after collection in a

wet air pollution control device such as a scrubber,

“wet” baghouse, etc. This subcategory also includes

those non—electric furnace smelting operations, such as

exothermic (i.e., aluminothermic or silicothermic)

smelting, ferromanganese refining, etc., where these

are controlled for air pollution by wet air pollution

control devices. This subcategory does not include

noncontact cooling water or those furnaces which

utilize dry dust collection techniques, such as dry

baghouses.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 424.21 (19&69A). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

---

56

ci)

New sources:

1) The Board incorporates by reference 40 CFR 424.26

(19&694)~asamended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 18, 1973.

(Source: Amended at

_____

Ill. Reg.

________,

effective

___________________________________________________ )

Section 307.3403 Slag Processing

a) Applicability. This Section applies to discharges

resulting from slagprocessing in which:

1) The residual metal values in the furnace slag are

recovered via concentration for return to the

furnace; or

2) The slag is “shotted” for further use.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 424.31 (l98-6~.j). This incorporation

includes no later amendments or editions.

C)

Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 424.36

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards

*

---

57

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 18, 1973.

(Source: Amended at

______,

Ill. Reg.

________,

effective

SUBPART BA: GLASS MANUFACTURING

Section 307.3601 Insulation Fiberglass

a) Applicability. This Section applies to discharges

resulting from the production of insulation fiberglass

in which molten glass is either directly or indirectly

made, continuously fiberized and chemically bonded into

a wool-like material.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.11 (1984.~j). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 426.16

(1984~), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 22, 1973.

(Source: Amended at

_____

Ill. Reg.

_________,

effective

___________________________________________________ )

Section 307.3602 Sheet Glass Manufacturing

a) Applicability. This Section applies to discharges

resulting from the process in which several mineral

ingredients (sand, soda ash, limestone, dolomite,

cullet and other ingredients) are mixed, melted in a

---

58

furnace, and drawn vertically from a melting tank to

form sheet glass.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.21 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 426.24

(198494). as amended at 60 Fed, Rea. 33926

effective June 29~ 199~. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.26

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2)

No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 17, 1973.

(Source: Amended at

______

Ill. Reg.

_________,

effective

_____________________________________________________ )

Section 307.3603 Rolled Glass Manufacturing

a) Applicability. This Section applies to discharges

resulting from the process in which several mineral

ingredients (sand, soda ash, limestone, dolomite,

cullet and other ingredients) are mixed, melted in a

furnace and cooled by rollers to form rolled glass.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.31 (1984~). This incorporation

includes no later amendments or editions.

---

59

C)

Existing sources:

1) The Board incorporates by reference 40 CFR 426.34

(198-6~), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.36

(198494). as amended at 60 Fed. Req. 339296

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 17, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

_____________________________________________________ )

Section 307.3604 Plate Glass Manufacturing

a) Applicability. This Section applies to discharges

resulting from the process in which several mineral

ingredients (sand, soda ash, limestone, dolomite,

cullet and other ingredients) are melted in a furnace,

pressed between rollers and finally ground and polished

to form plate glass.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.41 (1984~). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 426.44

(l984~j).as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

60

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.4~

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 17, 1973.

(Source: Amended at

Ill. Reg.

effective

____________________________________________)

Section 307.3605 Float Glass Manufacturing

a) Applicability. This Section applies to discharges

resulting from the process in which several mineral

ingredients (sand, soda ash, limestone, dolomite,

cullet and other ingredients) are mixed, melted in a

furnace and floated on a molten tin bath to produce

float glass.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.51 (l9&6~j). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart 13.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.5&~.

(1984~). as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

---

61

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 17, 1973.

(Source: Amended at

Ill. Reg.

,

effective

_____________________________________________________)

Section 307.3606 Automotive Glass Tempering

a) Applicability. This Section applies to discharges

resulting from the processes in which glass is cut and

then passed through a series of processes that grind

and polish the edges, bend the glass and then temper

the glass to produce side and back windows for

automobiles.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.61 (l984~.j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 426.64

(1984~)~asamended at 60 Fed. Reg. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.66

(1984~). as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

62

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 17, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

Section 307.3607 Automotive Glass Laminating

a) Applicability. This Section applies to discharges

resulting from the processes which laminate a plastic

sheet between two layers of glass, or which prepare the

glass for lamination such as cutting, bending and

washing, to produce automobile windshields.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.71 (198-694). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.76

(19’8-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 17, 1973.

(Source: Amended at

Ill. Req.

_________.

effective

Section 307.3608 Glass Container Manufacturing

a) Applicability. This Section applies to discharges

resulting from the process by which raw materials are

melted in a furnace and mechanically processed into

glass containers.

---

63

b) Specialized definitions. The Board incorporates by

ref eren~e 40 CFR 426.81 (198-614J. This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.86

(1984~j).as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 21, 1974.

(Source: Amended at

______

Ill. Reg.

_________,

effective

__________________________________________________ )

Section 307.3610 Glass Tubing (Danner) Manufacturing

a) Applicability. This Section applies to discharges

resulting from the process by which raw materials are

melted in a furnace and glass tubing mechanically drawn

from the furnace horizontally by means of the Danner

process, which requires the intermittent quenching of

cullet.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.101 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.106

(1984~), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

64

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 21, 1974.

(Source: Amended at

Ill. Reg.

_________,

effective

Section 307.3611 Television Picture Tube Envelope

Manufacturing

a) Applicability. This Section applies to discharges

resulting from the process by which raw materials are

melted in a furnace and processed into television

picture tube envelopes.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.111 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.116

(198-694). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 21, 1974.

(Source: Amended at

Ill. Reg.

_________

effective

---

65

Section 307.3612 Incandescent Lamp Envelope Manufacturing

a) Applicability. This Section applies to discharges

resulting from the processes by which:

1) Raw materials are melted in a furnace and

mechanically processed into incandescent lamp

envelopes; or

2) Incandescent lamp envelopes are etched with

hydrofluoric acid to produce frosted envelopes.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.121 (198-62.4.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.126

(1984~4.), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 21, 1974.

(Source: Amended at

Ill. Reg.

________,

effective

________________________________________________________ )

Section 307.3613 Hand Pressed and Blown Glass Manufacturing

a) Applicability. This Section applies to discharges

resulting from the process by which raw materials are

melted in a furnace and processed by hand into pressed

or blown glassware. This includes those plants which:

1) Produce leaded glass and employ hydrofluoric acid

finishing techniques;

2) Produce non—leaded glass and employ hydrofluoric

acid finishing techniques; or

---

66

3) Produce leaded or non—leaded glass and do not

employ hydrofluoric acid finishing techniques.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 426.131 (198414.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 426.136

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 21, 1974.

(Source: Amended at

Ill. Reg.

_________,

effective

______________________________________________________ )

SUBPART BB: ASBESTOS MANUFACTURING

Section 307.3701 Asbestos—Cement Pipe

a) Applicability. This Section applies to discharges

resulting from the process in which asbestos, Portland

cement, silica and other ingredients are used in the

manufacturing of asbestos—cement pipe.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.11 (198414.). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 427.14

(198-694), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

---

67

2)

No person subject to the pretreatment

standards

incorporated by reference in subsection (I) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 427.16

(198494), as amended at 60 Fed. Reg. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 30, 1973.

(Source: Amended at

Ill. Reg.

________,

effective

Section 307.3702 Asbestos-Cement Sheet

a) Applicability. This Section applies to discharges

resulting from the process in which asbestos, Portland

cement, silica and other ingredients are used in the

manufacturing of asbestos—cement sheets. Discharges

resulting from manufacture of asbestos—cement sheet

laboratory tops are specifically excluded from the

provisions of this Section.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.21 (198414.). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 427.24

(l9&6~.4.), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

68

d) New sources:

1) The Board incorporates by reference 40 CFR 427.26

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 30, 1973.

(Source: Amended at

Ill. Req.

__________,

effecitve

______________________________________________

)

Section 307.3703 Asbestos Paper (Starch Binder)

a) Applicability. This Section applies to discharges

resulting from the process in which asbestos, starch

binders and other ingredients are used in the

manufacture of asbestos paper (starch binder).

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.31 (1984~4.). This incorporation

includes no later amendments or editions.

C)

Existing sources:

1) The Board incorporates by reference 40 CFR 427.34

(1984~4.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 427.36

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

---

69

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 30, 1973.

(Source: Amended at

Ill. Reg.

__________,

effective

______________________________________________________)

Section 307.3704 Asbestos Paper (Elastomeric Binder)

a) Applicability. This Section applies to discharges

resulting from the process in which asbestos,

elastomeric binder and other ingredients are used in

the manufacture of asbestos paper (elastomeric binder).

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.41 (198-61j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 427.44

(198-694), as amended at 60 Fed. Rea. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 427.46

(198414.). as amended at 60 Fed. Req.

33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

70

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 30, 1973.

(Source: Amended at

Ill. Reg.

effective

_____________________________________________________ )

Section 307.3705 Asbestos Millboard

a) Applicability. This Section applies to discharges

resulting from the process in which asbestos in

combination with various other materials such as

cement, starch, clay, lime and mineral wool are used in

the manufacture of asbestos millboard.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.51 (198414.). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 427.54

(1984~j),as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 427.56

(198-6-94), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 30, 1973.

(Source: Amended at

______

________

)

______

Ill. Req.

________,

effective

---

71

Section 307.3706 Asbestos Roofing

a) Applicability. This Section applies to discharges

resulting from the process in which asbestos paper is

saturated with asphalt or coal tar with the subsequent

application of various surface treatments to produce

asbestos roofing products.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.61 (198-694). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 427.64

(19842.4.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 427.66

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 30, 1973.

(Source: Amended at

Ill. Req.

_________,

effective

____________________________________________

)

Section 307.3707 Asbestos Floor Tile

a) Applicability. This Section applies to discharges

resulting from the process in which asbestos, polyvinyl

chloride resin, chemical stabilizers, limestone and

other fillers are used in the manufacture of asbestos

floor tile.

---

72

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.71 (198-62j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 427.74

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

d) New sources:

1) The Board incorporates by reference 40 CFR 427.76

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 30, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

_____________________________________________________ )

Section 307.3708 coating or Finishing of Asbestos Textiles

a) Applicability. This Section applies to discharges

resulting from the process of coating or impregnating

asbestos textiles with materials which impart specific

desired qualities to the finished product.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.81 (19~8-6~.4.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

---

73

d) New sources:

1) The Board incorporates by reference 40 CFR 427.86

(19842.4.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 29, 1974.

(Source: Amended at

Ill. Reg.

_________,

effective

Section 307.3709 Solvent Recovery

a) Applicability. This Section applies to discharges

resulting from the process of solvent recovery in the

manufacture of asbestos products.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.91 (198-614.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 427.96

(1984j4.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

74

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 29, 1974.

(Source: Amended at

Ill. Reg.

_________,

effective

_________________________________________________

)

Section 307.3710 Vapor Absorption

a) Applicability. This Section applies to discharges

resulting from the removal of volatilized organic

materials from atmospheric emissions by means of wet

scrubbers.

b) Specialized definitions. The Board incorporates by

reference 40 CFR427.101 (198414.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 427.106

(198414.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 29, 1974.

(Source: Amended at

______

Ill. Req.

__________,

effective

_________________________________________________

)

Section 307.3711 Wet Dust Collection

a) Applicability. This Section applies to discharges

resulting from the removal of dust (particulates) from

atmospheric emissions by means of wet scrubbers.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 427.111 (19842.4.). This incorporation

includes no later amendments or editions.

---

75

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 427.116

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2)

No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 29, 1974.

(Source: Amended at

Ill. Req.

,

effective

__________________________________________________ )

SUBPART BC: RUBBER MANUFACTURING

Section 307.3801 Tire and Inner Tube Plants

a) Applicability. This Section applies to discharges

resulting from the production of pneumatic tires and

inner tubes in tire and inner tube plants.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 428.11 (19842.4.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 428.16

(198-694). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

---

76

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 18, 1979.

(Source: Amended at

______

Ill. Reg.

_________,

effective

Section 307.3804 Latex Rubber

a) Applicability. This Section applies to discharges

resulting from the manufacture of latex rubber.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 428.41 (l984~j). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 428.46

(198414.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 18, 1979.

(Source: Amended at

______

Ill. Reg.

_________,

effective

_______________________________________________)

Section 307.3805 Small-Sized General Molded, Extruded and

Fabricated Rubber Plants

a) Applicability. This Section applies to discharges

resulting from the production of molded, extruded or

fabricated rubber products, foam rubber backing, rubber

cement-dipped goods or retreaded tires by small-sized

plants. Specifically excluded from this Section are

discharges resulting from the production of latex-based

---

77

products, tires and inner tubes, and those discharges

from textile plants subject to Subpart K.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 428.51 (19842.4.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 428.56

(198-694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 18, 1979.

(Source: Amended at

Ill. Req.

_________,

effective

Section 307.3806 Medium-Sized General Molded, Extruded and

Fabricated Rubber Plants

a) Applicability. This Section applies to discharges

resulting from the production of molded, extruded or

fabricated rubber products, foam rubber backing, rubber

cement-dipped goods or retreaded tires by medium—sized

plants. Specifically excluded from this Section are

discharges resulting from the production of latex—based

products, tires and inner tubes, and discharges from

textile plants subject to the provisions of Subpart K.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 428.61 (l984~4.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

---

78

ci)

New sources:

1) The Board incorporates by reference 40 CFR 428.66

(19&694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 18, 1979.

(Source: Amended at

Ill. Reg.

________,

effective

______________________________________________________)

Section 307.3807 Large-Sized General Molded, Extruded and

Fabricated Rubber Plants

a) Applicability. This Section applies to discharges

resulting from the production of molded, extruded or

fabricated rubber products, foam rubber backing, rubber

cement—dipped goods or retreaded tires by large-sized

plants. Specifically excluded from this Section are

discharges resulting from the production of latex—based

products, tires and inner tubes, and discharges from

textile plants subject to Subpart K.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 428.71 (19842.4.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 428.76

(19&62.4j, as amended at 60 Fed. Req. 33926

effective June

29, 1995.

This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

79

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 18, 1979.

(Source: Amended at

Ill. Reg.

_________,

effective

___________________________________________________)

Section 307.3808 Wet Digestion Reclaimed Rubber

a) Applicability. This Section applies to discharges

resulting from the production of reclaimed rubber by

use of the wet digestion process.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 428.81 (198414.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 428.86

(l984~j)fl as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POPW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 18, 1979.

(Source: Amended at

Ill. Reg.

effective

_________________________________________________

)

Section 307.3809 Pan, Dry Digestion and Mechanical Reclaimed

Rubber

a) Applicability. This Section applies to discharges

resulting from the production of reclaimed rubber

except when produced by the wet digestion process.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 428.91 (198-6~4.). This incorporation

includes no later amendments or editions.

---

80

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 428.96

(19-8494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 18, 1979.

(Source: Amended at

Ill. Reg.

________,

effective

Section 307.3810 Latex-Dipped, Latex-Extruded and Latex-Molded

Rubber

a) Applicability. This Section applies to discharges

resulting from the manufacture of latex—dipped, latex—

extruded or latex-molded products with the exception of

discharges from textile plants subject to Subpart K.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 428.101 (1984~4.). This incorporation

includes no later amendments or editions.

C)

Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 428.106

(198414.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

81

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after December 18, 1979.

(Source: Amended at

Ill. Reg.

__________,

effective

________________________________________________ )

Section 307.3811 Latex Foam

a) Applicability. This Section applies to discharges

resulting from the manufacture of latex foam except for

discharges from textile plants subject to Subpart K.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 428.111 (198414.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 428.116

(198494), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference

in

subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3)

“New source” means any building, structure,

facility or installation the construction of which

commenced after December 18, 1979.

(Source: Amended at

Ill. Reg.

,

effective

_____________________________________________________ )

SUBPART BG: MEAT PRODUCTS

Section 307.4201 Simple Slaughterhouse

a) Applicability. This Section applies to discharges

resulting from the production of red meat carcasses, in

whole or part, by simple slaughterhouses.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.11 (198414.). This incorporation

includes no later amendments or editions.

---

82

c) Existing sources:

1) The Board incorporates by reference 40 CFR 432.14

(198494), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 432.16

(19842.4.)~as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 29, 1973.

(Source: Amended at

Ill. Reg.

_________,

effective

________________________________________

)

Section 307.4202 Complex Slaughterhouse

a) Applicability. This Section applies to discharges

resulting from the production of red meat carcasses, in

whole or part, by complex slaughterhouses.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.21 (1984~4.). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 432.24

(198-62.4.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

---

83

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 432.26

(198414.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 29, 1973.

(Source: Amended at

Ill. Req.

_______,

effective

Section 307.4203 Low-Processing Packinghouse

a) Applicability. This Section applies to discharges

resulting from the production of red meat carcasses in

whole or part, by low—processing packinghouses.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.31 (1984~j). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 432.34

(198414.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

84

ci) New sources:

1) The Board incorporates by reference 40 CFR 432.36

(198414.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 29, 1973.

(Source: Amended at

Ill. Reg.

_______,

effective

Section 307.4204 High-Processing Packinghouse

a) Applicability. This Section applies to discharges

resulting from the production of red meat carcasses, in

whole or part, by high-processing packinghouses.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.41 (198494). This incorporation

includes no later amendments or editions.

c) Existing sources:

1) The Board incorporates by reference 40 CFR 432.44

(198-694). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

ci) New sources:

1) The Board incorporates by reference 40 CFR 432.46

(198414.), as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

---

85

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after October 29, 1973.

(Source: Amended at

Ill. Reg.

__________,

effective

___________________________________________________)

Section 307.4205 Small Processor

a) Applicability. This Section applies to discharges

resulting from the production of finished meat products

such as fresh meat cuts, smoked products, canned

products, hams, sausages, luncheon meats or similar

products by a small processor.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.51 (198-694). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 432.56

(1984~4.), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 28, 1974.

(Source: Amended at

______

Ill. Reg.

_________,

effective

___________________________________________________)

---

86

Section 307.4206 Meat Cutter

a) Applicability. This Section applies to discharges

resulting from the fabrication or manufacture of fresh

meat cuts such as steaks, roasts, chops, etc. by a meat

cutter.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.61 (198494.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 432.66

(198-694). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 28, 1974.

(Source: Amended at

______

Ill. Reg.

-

,

effective

________________________________________________ )

Section 307.4207 Sausage and Luncheon Meats Processor

a) Applicability. This Section applies to discharges

resulting from the manufacture of fresh meat cuts,

sausage, bologna and other luncheon meats by a sausage

and luncheon meat processor.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.71 (198694.). This incorporation

includes no later amendments or editions.

C)

Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

---

87

ci) New sources:

1) The Board incorporates by reference 40 CFR 432.76

(198494.). as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards.

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 28, 1974.

(Source: Amended at

Ill. Reg.

________,

effective

Section 307.4208 Ham Processor

a) Applicability. This Section applies to discharges

resulting from the manufacture of hams alone or in

combination with other finished products by a ham

processor.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.81 (198494.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 432.86

(198494.). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

88

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 28, 1974.

(Source: Amended at

Ill. Reg.

effective

_______________________________________________)

Section 307.4209 Canned Meats Processor

a) Applicability. This Section applies to discharges

resulting from the manufacture of canned meats, alone

or in combination with any other finished products, by

a canned meats processor.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.91 (198-694). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 432.96

(198-694). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 28, 1974.

(Source: Amended at

Ill. Reg.

_________,

effective

_______________________________________________

)

Section 307.4210 Renderer

a) Applicability. This Section applies to discharges

resulting from the manufacture of meat meal, dried

animal by—product residues (tankage), animal oils,

grease and tallow, perhaps including hide curing, by a

renderer.

---

89

b) Specialized definitions. The Board incorporates by

reference 40 CFR 432.101 (198-694.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 432.106

(198494.). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTS~in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after August 28, 1974.

(Source: Amended at

______

Ill. Reg.

________,

effective

SUBPART BR: PAVING AND ROOFING MATERIALS (TARS AND ASPHALT)

Section 307.5301 Asphalt Emulsion

a) Applicability. This Section applies to discharges

resulting from the production of asphalt paving and

roofing emulsions.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 443.11 (198494). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 443.16

(1984~j). as amended at 60 Fed. Req. 33926

effective June 29. 1995. This incorporation

includes no later amendments or editions.

---

90

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after January 10, 1975.

(Source: Amended at

Ill. Reg.

_________,

effective

________________________________________________________ )

Section 307.5302 Asphalt Concrete

a) Applicability. This Section applies to discharges

resulting from the production of asphalt concrete.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 443.21 (198.694.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 443.26

(198494.). as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after January 10, 1975.

(Source: Amended at

Ill. Req.

_________,

effective

_________________________________________________

)

Section 307.5303 Asphalt Roofing

a) Applicability. This Section applies to discharges

resulting from the production of asphalt roofing

materials.

---

91

b) Specialized definitions. The Board incorporates by

reference 40 CFR 443.31 (198694.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 443.36

(198414.) as amended at 60 Fed. Reg. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after January 10, 1975.

(Source: Amended at

Ill. Reg.

_________,

effective

Section 307.5304 Linoleum and Printed Asphalt Felt

a) Applicability. This Section applies to discharges

resulting from the production of linoleum and printed

asphalt felt floor coverings.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 443.41 (198694.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 443.46

(198-694), as amended at .60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

---

92

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after January 10, 1975.

(Source: Amended at

_______

Ill. Reg.

_________,

effective

SUBPART BU: PAINT FORMULATING

Section 307.5601 Oil—Base Solvent Wash Paint

a) Applicability. This Section applies to discharges

resulting from the production of oil—base paint where

the tank cleaning is performed using solvents.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 446.11 (198-694). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 446.16

(198694.) as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after February 26, 1975.

(Source: Amended at

______

Ill. Reg.

effective

---

93

SUBPART By: INK FORMULATING

Section 307.5701 Oil—Base Solvent Wash Ink

a) Applicability. This Section applies to discharges

resulting from the production of oil-base ink where the

tank washing system uses solvents.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 447.11 (198494.). This incorporation

includes no later amendments or editions.

C)

Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 447.16

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after February 26, 1975.

(Source: Amended at

Ill. Req.

_________,

effective

SUBPART CG: CARBON BLACK MANUFACTURING

Section 307.6801 Carbon Black Furnace Process

a) Applicability. This Section applies to discharges

resulting from production of carbon black by the

furnace process.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 458.11 (198494.). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

---

94

ci) New sources:

1) The Board incorporates by reference 40 CFR 458.16

(198.694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after May 18, 1976.

(Source: Amended at

Ill. Reg.

,

effective

Section 307.6802 Carbon Black Thermal Process

a) Applicability. This Section applies to discharges

resulting from the production of carbon black by the

thermal process.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 458.21 (198-694). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

d) New sources:

1) The Board incorporates by reference 40 CFR 458.26

(198694), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

---

95

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after May 18, 1976.

(Source: Amended at

Ill. Reg.

_________,

effective

________________________________________)

Section 307.6803 Carbon Black Channel Process

a) Applicability. This Section applies to discharges

resulting from the production of carbon black by the

channel process.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 458.31 (198694). This incorporation

includes no later amendments or editions.

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 458.36

(198-694)., as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after May 18, 1976.

(Source: Amended at

Ill. Req.

________,

effective

___________________________________________

)

Section 307.6804 Carbon Black Lamp Process

a) Applicability. This Section applies to discharges

resulting from the production of carbon black by the

lamp process.

b) Specialized definitions. The Board incorporates by

reference 40 CFR 458.41 (198494.). This incorporation

includes no later amendments or editions.

---

96

c) Existing sources: These sources shall comply with the

general and specific pretreatment requirements of

Subpart B.

ci) New sources:

1) The Board incorporates by reference 40 CFR 458.46

(198494), as amended at 60 Fed. Req. 33926

effective June 29, 1995. This incorporation

includes no later amendments or editions.

2) No person subject to the pretreatment standards

incorporated by reference in subsection (1) shall

cause, threaten or allow the discharge of any

contaminant to a POTW in violation of such

standards.

3) “New source” means any building, structure,

facility or installation the construction of which

commenced after May 18, 1976.

(Source: Amended at

Ill. Req.

________,

effective

TITLE 35 ENVIRONMENTAL PROTECTION

SUBTiTLE C: WATER POLLUTION

CHAPTER I: POLLUTION CONTROL BOARD

PART 309

PERMITS

SUBPART A: NPDES PERMITS

Section 309.103

Application

-

General

a) Application Forms

1) An applicant for a National Pollution Discharge

Elimination System (NPDES) Permit shall file an

application, in accordance with Section 309.223

hereof, on forms provided by the Illinois

Environmental Protection Agency (Agency). Such

forms shall comprise the NPDES application forms

promulgated by the U.S. Environmental Protection

Agency for the type of discharge for which an

NPDES Permit is being sought and such additional

information as the Agency may reasonably require

in order to determine that the discharge or

proposed discharge will be in compliance with

applicable state and federal requirements.

---

97

2) In addition to the above application forms, the

Agency may require the submission of plans and

specifications for treatment works and summaries

of design criteria.

3) Effluent toxicity monitoring

A) In addition to the above application forms,

the Agency may require, pursuant to Section

39 of the Act, the installation, use,

maintenance and reporting of results from

monitoring equipment and methods, including

biological monitoring. The Agency may

require, pursuant to Section 39 of the Act,

effluent toxicity testing to show compliance

with 35 Ill. Acim. Code 302.621 and 302.630.

If this toxicity testing shows the effluent

to be toxic, the Agency may require pursuant

to Section 39 of the Act further testing and

identification of the toxicant(s) pursuant to

35 Ill. Adm. Code 302.210(a).

B) The following POTWs shall provide the results

of valid whole effluent biological toxicity

testing to the Agency:

i) All POTWs with design influent flows

equal to or greater than one million

gallons per day;

ii) All POTWs with approved pretreatment

programs or POTWs required to develop a

pretreatment program pursuant to 35 Ill.

Adm. Code 310.Subpart E;

C) In addition to the POTWs listed in (a) (3) (B),

the Agency may require other POTWs to submit

the result of toxicity tests with their

permit applications, based on consideration

of the following factors.

i) The variability of the pollutants or

pollutant parameters in the POTW

effluent (based on chemical-specific

information, the type of treatment

facility, and types of industrial

contributors);

ii) The dilution of the effluent in the

receiving water (ratio of effluent flow

to receiving stream flow);

---

98

iii) Existing controls on point or nonpoint

sources, including total maximum daily

load calculations for the waterbody

segment and the relative contribution of

the POTW;

iv) Receiving stream characteristics,

including possible or known water

quality impairment, and whether the POTW

discharges to a coastal water, one of

the Great Lakes, or a water designated

as an outstanding natural resource; or

v) Other considerations (including but not

limited to the history of toxic impact

and compliance problems at the POTW),

which the Agency determines could cause

or contribute to adverse water quality

impacts.

D) The POTWe required under subsections

(a) (3) (B) or (a) (3) (C) to conduct toxicity

testing shall use the methods prescribed at

35 Ill. Adm. Code 302.Subpart F. Such

testing must have been conducted since the

later of the last NPDES permit reissuance or

permit modification pursuant to Section

309.182, 309.183 or 309.184 for any of the

reasons listed at 40 CFR 122.62(a) (199~),

as amended at 60 Fed. Rep. 33926 effective

June 29, 1995 herein incorporated by

reference (including no later amendments or

editions).

4) All POTWs with approved pretreatment programs

shall provide the following information to the

Agency: a written technical evaluation of the

need to revise local limits pursuant to 35 Ill.

Adm. Code 310.210.

BOARD NOTE: Subsections (a) (3) (B) through (a) (4)

are derived from 40 CFR 122.21(j) (19994.), a~

amcndcd at 55 Fed. flcg. 3-0-128 (July 24, 1~9-O-)-.

b) Animal Waste Facilities

An applicant for an NPDES Permit in connection with the

operation of an animal waste facility shall complete,

sign, and submit an NPDES application in accordance

with the provisions of 35 Ill. Acm. Code: Subtitle E,

Chapter I.

---

99

C)

Mining Activities

1) If, as defined by 35 Ill. Adm. Code 402.101,

mining activities are to be carried out on a

facility for which an NPDES Permit is held or

required, the applicant must submit a permit

application as required by 35 Ill. Adm. Code

403.103, 403.104 and 405.104. If the facility

will have a discharge other than a mine discharge

or non—point source mine discharge as defined by

35 Ill. Adm. Code 402.101, the applicant shall

also submit an NPDES Permit application in

accordance with Section 309.223 on forms supplied

by the Agency.

2) As provided by 35 Ill. Adm. Code 403.101, except

to the extent contradicted in 35 Ill. Adm. Code:

Subtitle D, Chapter I, the rules contained in this

Subpart apply only to 35 Ill. Adm. Code: Subtitle

D, Chapter I NPDES Permits.

3) As provided by 35 Ill. Adm. Code 406.100, except

to the extent provided in 35 Ill. Adm. Code:

Subtitle D, Chapter I, the effluent and water

quality standards of 35 Ill. Adm. Code 302, 303

and 304 are inapplicable to mine discharges and

non—point source mine discharges.

ci) New Discharges

Any person whose discharge will begin after the

effective date of this Subpart A or any person having

an NPDES Permit issued by the U.S. Environmental

Protection Agency for an existing discharge which will

substantially change in nature, or increase in volume

or frequency, must apply for an NPDES Permit either:

1) No later than 180 days in advance of the date on

which such NPDES Permit will be required; or

2) In sufficient time prior to the anticipated

commencement of the discharge to insure compliance

with the requirements of Section 306 of the Clean

Water Act (CWA) (33 U.S.C. 1251 et seq), or with

any other applicable water quality standards and

applicable effluent standards and limitations.

e) Signatures

An application submitted by a corporation shall be

signed by a principal executive officer of at least the

level of vice president, or his duly authorized

---

100

representative, if such representative is responsible

for the overall operation of the facility from which

the discharge described in the application form

originates. In the case of a partnership of a sole

proprietorship, the application shall be signed by a

general partner or the proprietor, respectively. In

the case of a publicly owned facility, the application

shall be signed by either the principal executive

officer, ranking elected official, or other duly

authorized employee.

(Source: Amended at

Ill. Reg.

____________,

effective

TITLE 35: ENVIRONMENTAL PROTECTION

SUBTITLE C: WATER POLLUTION

CHAPTER I: POLLUTION CONTROL BOARD

PART 310

PRETREATMENT PROGRAMS

SUBPART A: GENERAL PROVISIONS

Section 310.103

Federal Law

a) The Board intends that this Part be identical in

substance with the pretreatment requirements of the

Clean Water Act (33 USC 1251 et seq) and United States

Environmental Protection Agency (USEPA) regulations at

40 CFR 401 et seq. (198494.). as amended at 60 Fed. Req.

33926 effective June 29, 1995.

b) This Part will allow the Agency to issue pretreatment

permits, review POTW pretreatment plans and authorize

POTW’s to issue authorizations to discharge to

industrial users when and to the extent USEPA

authorizes the Illinois pretreatment program pursuant

to the Clean Water Act. After authorization the

requirements of the Clean Water Act and 40 CFR 401 et

seq. will continue in Illinois. In particular, USEPA

will:

1) Retain the right to request information pursuant

to 40 CFR 403.8(f) (198494.). as amended at 60 Fed.

Req. 33926 effective June 29, 1995 and

2) Retain the right to inspect and take samples

pursuant to 40 CFR 403.12(1).

---

101

c) This Part shall not be construed as exempting any

person from compliance, prior to authorization of the

Illinois pretreatment program, with the pretreatment

requirements of the Clean Water Act, USEPA regulations

and NPDES permit conditions.

ci) POTW pretreatment programs which have been approved by

USEPA pursuant to 40 CFR 403 will be deemed approved

pursuant to this Part, unless the Agency determines

that it is necessary to modify the POTW pretreatment

program to be consistent with State law.

1) The Agency shall notify the POTW of any such

determination within 60 days after approval of the

program by USEPA, or within 60 days after USEPA

authorizes the Illinois pretreatment program,

whichever is later.

2) If the Agency so notifies the POTW, the POTW will

apply for program approval pursuant to Section

310.501 et seq.

e) USEPA’s access to Agency records and information in

possession of the Agency shall be governed by the

memorandum of agreement between USEPA and the Agency,

subject to confidentiality requirements in Section

310.105.

Section 310.107

Incorporations by Reference

a) The following publications are incorporated by

reference:

1) The consent decree in NRDC v. Costle, 12

Environment Reporter Cases 1833 (D.C. Cir. August

16, 1978).

2) Standard Industrial Classification Manual (1972),

and 1977 Supplement, republished in 1983,

available from the Superintendent of Documents,

U.S. Government Printing Office, Washington, D.C.

2040..

b) The following provisions of the Code of Federal

Regulations are incorporated by reference:

40 CFR 2.302 (19&994.)

-

40 CFR 25 (19&9~9j)

40 CFR 122, Appendix D, Tables II and III (198.92.4.)

---

102

40 CFR 128.140(b) (1977)

40 CFR 136 (198-994), as amended at 60 Fed. Req.

17160, April 4. 1995

40 CFR 403 (198-9.94.), as amended at 60 Fed. Req.

33926 effective June 29, 1995.

40 CFR 403, Appendix D (1989.94.)

c) The following federal statutes are incorporated by

reference:

1) Section 1001 of the Criminal Code (18 U.S.C. 1001)

as of July 1, 1988

2) Clean Water Act (33 U.S.C. 1251 et seq) as of July

1, 1988

3) Subtitles C and D of the Resource Conservation and

Recovery Act (42 U.S.C. 6901 et seq.) as of July

1, 1988

ci) This Part incorporates no future editions or

amendments.

(Source: Amended at ______Ill. Reg.

________,

effective

SUBPART D: POTW TREATMENT PROGRAMS

Section 310.510

Pretreatment Program Requirements

A POTW pretreatment program shall meet the following

requirements:

a) Legal authority. The POTW shall operate pursuant to

legal authority enforceable in federal, state or local

courts, which authorizes or enables the POTW to apply

and to enforce the requirements of this Part and 35

Ill. Adm. Code 307. Such authority may be contained in

a statute, ordinance or series of joint powers

agreements which the POTW is authorized to enact, enter

into or implement, and which are authorized by State

law. At a minimum, this legal authority shall enable

the POTW to:

1) Deny or condition new or increased contributions

of pollutants or changes in the nature of

pollutants, to the POTW by industrial users where

such contributions do not meet applicable

---

103

pretreatment standards and requirements or where

such contributions would cause the POTW to violate

its NPDES permit;

2) Require compliance with applicable pretreatment

standards and requirements by industrial users;

3) Control, through ordinance, permit order or

similar means, the contribution to the POTW by

each industrial user to ensure compliance with

applicable pretreatment standards and

requirements;

4) Require:

A)

The development of a

compliance schedule by

each industrial user for the installation of

technology required to meet applicable

pretreatment standards and requirements; and

B) The submission of all notices and self—

monitoring reports from industrial users as

are necessary to assess and assure compliance

by industrial users with pretreatment

standards and requirements, including, but

not limited, to the reports required in

Subpart F;

5) Carry out all inspection, surveillance and

monitoring procedures necessary to determine,

independent of information supplied by industrial

users, compliance or noncompliance with applicable

pretreatment standards and requirements by

industrial users. Representatives of the POTW

shall be authorized to enter any premises of any

industrial user in which a discharge source or

treatment system is located or in which records

are required to be kept under Section 310.634 to

assure compliance with pretreatment standards.

Such authority shall be at least as extensive as

the authority provided under Section 308 of the

CWA;

6) Obtain remedies for noncompliance by any

industrial user with any pretreatment standard or

requirement.

A) All POTW’s shall be able to seek injunctive

relief for noncompliance by industrial users

with pretreatment standards or requirements.

---

104

All POTW’s shall also have authority to seek

or assess civil or criminal penalties in at

least the amount of $1000 a day for each

violation by industrial users of pretreatment

standards and requirements. POTW’s whose

approved pretreatment programs require

modification to conform to the requirements

of this subsection shall submit a request by

November 16, 1989.

B) Pretreatment requirements which will be

enforced through the remedies set forth in

subsection (a) (6) (A) will include but not be

limited to: the duty to allow or carry out

inspections, entry or monitoring activities;

any rules, regulations or orders issued by

the POTW; or any reporting requirements

imposed by the POTW, this Part or 35 Ill.

Adm. Code 307. The POTW shall have authority

and procedures (after notice to the

industrial user) immediately and effectively

to halt or prevent any discharge of

pollutants to the POTW which reasonably

appears to present an imminent endangerment

to the health or welfare of persons. The

POTW shall also have authority and procedures

(which shall include notice to the affected

industrial users and an opportunity to

respond) to halt or prevent any discharge to

the POTW which presents or may present an

endangerment to the environment or which

threatens to interfere with the operation of

the POTW. The Agency shall have authority to

seek judicial relief for noncompliance by

industrial users when the POTW has acted to

seek such relief but has sought a penalty

which the Agency finds to be insufficient.

The procedures for notice to industrial users

where the POTW is seeking ex parte temporary

judicial injunctive relief will be governed

by applicable state or federal law and not by

this provision; and

7) Comply with the confidentiality requirements set

forth in Section 310.105

b) Procedures. The POTW shall develop and implement

procedures to ensure compliance with the requirements

of a pretreatment program. At a minimum, these

procedures shall enable the POTW to:

---

105

1) Identify and locate all possible industrial users

which might be subject to the POTW pretreatment

program. Any compilation, index or inventory of

industrial users made under this subsection shall

be made available to the Agency upon request.

2) Identify the character and volume of pollutants

contributed to the POTW by the industrial users

identified under subsection (b) (1). This

information shall be made available to the Agency

upon request.

3) Notify industrial users identified under

subsection (b) (1) of applicable pretreatment

standards and any applicable requirements under

Section 204(b) and 405 of the CWA and Subtitles C

and D of the Resource Conservation and Recovery

Act, incorporated by reference in Section 310.107.

4) Receive and analyze self—monitoring reports and

other notices submitted by industrial users in

accordance with the self—monitoring requirements

in Subpart D;

5) Randomly sample and analyze the effluent from

industrial users and conduct surveillance and

inspection activities in order to identify,

independent of information supplied by industrial

users, occasional and continuing noncompliance

with pretreatment standards. The results of these

activities shall be made available to the Agency

upon request;

6) Investigate instances of noncompliance with

pretreatment standards and requirements, as

indicated in the reports and notices required

under Subpart D or as indicated by analysis,

inspection and surveillance activities described

in subsection (b) (5). Sample taking and analysis,

and the collection of other information, shall be

performed with sufficient care to produce evidence

admissible in enforcement proceedings or in

judicial actions; and

7) Comply with the public participation requirements

of 40 CFR 25, incorporated by reference in Section

310.107, in the enforcement of pretreatment

standards. These procedures shall include

provision for providing, at least annually, public

notification, in a newspaper of general

circulation in the unit of local government in

which the POTW is located, of industrial users

---

106

which, during the previous 12 months, were

significantly violating applicable pretreatment

standards or other pretreatment requirements. For

the purposes of this provision, a significant

violation is a violation which remains uncorrected

45 days after notification of noncompliance; which

is part of a pattern of noncompliance over a

twelve month period; which involves a failure to

accurately report noncompliance; or which resulted

in the POTW exercising its emergency authority

under subsection (a) (6) (B).

c) The POTW shall have sufficient resources and qualified

personnel to carry the authorities and procedures

described in subsections (a) and (b).

ci) Local limits. The POTW shall develop local limits as

required in Section 310.210 or demonstrate that they

are not necessary.

BOARD NOTE: See 40 CFR 403.8(f) (198494), as amended

at 60 Fed. Req. 33926 effective June 29, 1995 53 Fcd.

Reg. 40612, October 17, 1988.

(Source: Amended at

Ill. Peg.

,

effective

________________________________________________________ )

SUBPART F: REPORTING REQUIREMENTS

Section 310.602

Baseline Report

Within the time limits specified in subsection (h), existing

industrial users subject to such categorical pretreatment

standards and currently discharging to or scheduled to discharge

to a POTW shall submit to the control authority a report which

contains the information listed in subsections (a) through (g).

New sources, and sources that become industrial users subsequent

to the promulgation of an applicable categorical standard, shall

submit to the control authority a report which contains the

information listed in subsections (a) through (e). Where reports

containing this information already have been submitted to the

USEPA in compliance with 40 CFR 128.140(b), incorporated by

reference in Section 310.107, the industrial user shall not be

required to submit this information again. New sources shall

also include in the report information on the method of

•pretreatment the source intended to use to meet applicable

pretreatment standards. New sources shall give estimates of the

information requested in subsections (ci) and (e).

---

107

a) Identifying information. The industrial user shall

submit the name and address of the facility including

the name of the operator and owners;

b) Permits. The industrial user shall submit a list of

any environmental control permits held by or for the

facility;

c) Description of operations. The industrial user shall

submit a brief description of the nature, average rate

of production and standard industrial classification

(SIC Code) of the operations carried out by such

industrial user. This description should include a

schematic process diagram which indicates points of

discharge to the POTW from the regulated processes.

ci)

Flow measurement. The industrial user shall submit

information showing the measured average daily and

maximum daily flow, in gallons per day, to the POTW

from each of the following:

1) Regulated process streams; and

2) Other streams as necessary to allow use of the

combined wastestream formula of Section 310.233.

(See subsection (e) (5)). The control authority

may allow for verifiable estimates of these flows

where justified by cost or feasibility

considerations.

e) Measurement of pollutants.

1) The industrial user shall identify the

pretreatment standards applicable to each

regulated process;

2) In addition, the industrial user shall submit the

results of sampling and analysis identifying the

nature and concentration (or mass, where required

by the standard or control authority) of regulated

pollutants in the discharge from each regulated

process. Both daily maximum and average

concentration (or mass, where required) shall be

reported. The sample shall be representative of

daily operations.

3) A

minimum

of four

(4)

grab samples must be used

for pH, cyanide, total phenols, oil and grease,

sulfide and volatile organics. For all other

pollutants, 24—hour composite samples must be

obtained through flow-proportional composite

sampling techniques where feasible. The control

---

108

authority shall waive flow proportional composite

sampling for any industrial user that demonstrates

that flow-proportional sampling is infeasible. In

such cases, samples shall be obtained through time

proportional composite sampling techniques or

through a minimum of four (4) grab samples where

the user demonstrates that this will provide a

representative sample of the effluent being

discharged.

4) The user shall take a minimum of one

representative sample to compile that data

necessary to comply with the requirements of this

subsection.

5) Samples shall be taken immediately downstream from

pretreatment facilities if such exist or

immediately downstream from the regulated process

if no pretreatment exists. If other wastewaters

are mixed with the regulated wastewater prior to

pretreatment the industrial user shall measure the

flows and concentrations necessary to allow use of

the combined wastestream formula of Section

310.233 in order to evaluate compliance with the

pretreatment standards. Where an alternate

concentration or mass limit has been calculated in

accordance with Section 310.233, this adjusted

limit along with supporting data shall be

submitted to the control authority;

6) Analytical methods.

A) The Board incorporates by reference 40 CFR

403.12(b) (198-8-94), as amended at 60 Fed.

Req. 33926 effective June 29. 1995. This

Part incorporates no future amendments or

editions.

B) Sampling and analysis shall be performed in

accordance with the techniques prescribed in

35 Ill. Adm. Code 307.1003. When 35 Ill.

Adm. Code 307.1003 does not reference

sampling or analytical techniques for the

pollutant in question ~r where USEPA has

determined that sampling and analysis

techniques are inappropriate pursuant to 40

CFR 403.12(b), sampling and analysis shall be

performed by using validated analytical

methods or any other applicable sampling and

analytical procedures, approved by the

Agency, including procedures suggested by the

POTW or other parties;

---

109

7) The control authority may allow the submission of

a baseline report which utilizes only historical

data so long as the data provides information

sufficient to determine the need for industrial

pretreatment measures;

8) The baseline report shall indicate the time, date

and place of sampling, and methods of analysis,

and shall certify that such sampling and analysis

is representative of normal work cycles and

expected pollutant discharges to the POTW.

f) Certification. A statement, reviewed by an authorized

representative of the industrial user (as defined in

Section 310.633) and certified to by a qualified

professional, indicating whether pretreatment standards

are being met on a consistent basis, and, if not,

whether additional operation and maintenance (0 and

M)

or additional pretreatment is required for the

industrial user to meet the pretreatment standards and

requirements; and

g) Compliance schedule. If additional pretreatment or 0

and M will be required to meet the pretreatment

standards; the shortest schedule by which the

industrial user will provide such additional

pretreatment or 0 and M. The completion date in this

schedule shall not be later than the compliance date

established for the applicable pretreatment standard.

1) Where the industrial user’s categorical

pretreatment standard has been modified by a

removal allowance (Subpart C), by the combined

wastestream formula (Section 310.233) or a

fundamentally different factors determination

(Subpart E) at the time the user submits the

report required by this Section, the information

required by subsections (f) and (g) shall pertain

to the modified limits.

2) If the categorical pretreatment standard is

modified by a removal allowance (Subpart C), by

the combined wastestream formula (Section 310.233)

or a fundamentally different factors determination

(Subpart E) after the user submits the report

required by this Section, any necessary amendments

to the information requested by subsections (f)

and (g) shall be submitted by the user to the

control authority within 60 days after the

modified limit is approved.

---

110

h) Deadlines for baseline reports.

1) For standards adopted by USEPA prior to

authorization of the Illinois pretreatment

program, baseline reports must be submitted

pursuant to 40 CFR 403.12(b).

2) For standards adopted by USEPA after authorization

of the Illinois pretreatment program:

A) Baseline reports for existing sources are due

within 180 days after the Board adopts or

incorporates a categorical pretreatment

standard or 180 days after the final

administrative decision made upon a category

determination submission under Section

310.221(d), whichever is later.

B) New sources and sources that become

industrial users subsequent to the

promulgation of an applicable categorical

standard shall submit the baseline report

within 90 days before beginning discharge.

C) New sources already in existence and

discharging on the date the Board adopts or

incorporates a categorical pretreatment

standard or 180 days after the final

administrative decision made upon a category

determination submission under Section

310.221(d), as described for existing sources

under subsection (h) (1) (A), are considered

existing sources for the purposes of the due

date provisions of this subsection.

BOARD NOTE: Derived from 40 CFR 403.12(b)

(198.8-94), as amended at 53 Fed. Req. 40613,

October 17, 1988.

(Source: Amended at

______

Ill. Reg.

_________,

effective

__________________________________________________ )

SUBPART G: FUNDAMENTALLY DIFFERENT FACTORS

Section 310.711 Application Deadline

a) Request for an FDF determination and supporting

information must be submitted in writing to the Agency.

---

111

b) In order to be considered, requests for FDF

determinations must be submitted within the following

time limits:

1) Prior to authorization of the Illinois program,

FDF requests must be directed to USEPA pursuant to

40 CFR 403.13 (198-694),as amended at 60 Fed. Req.

33926 effective June 29, 1995.

2) For standards adopted by USEPA after authorization

of the Illinois pretreatment program, the

industrial user shall request an FDF determination

within 180 days after the Board adopts or

incorporates the standard by reference unless the

user has requested a category determination

pursuant to Section 310.221.

c) Where the industrial user has requested a category

determination pursuant to Section 310.221, the user may

elect to await the results of the category

determination before submitting a request for an FDF

determination. Where the user so elects, the user

shall submit the request within 30 days after a final

decision has been made on the categorical determination

pursuant to Section 310.221(d).

(Board Note: Derived from 40 CFR 403.13(g) (1986))

(Source: Amended at

Ill. Peg.

_________,

effective

SUBPART J: BYPASS

Section 310.910

Definitions

“Bypass” means the intentional diversion of

wastestreams from any portion of an industrial user’s

treatment facility.

“Severe property damage” means substantial physical

• damage to property, damage to treatment facilities

which causes them to become inoperable or substantial

and permanent loss of natural resources which can

reasonably be expected to occur in the absence of a

bypass. Severe property damage does not mean economic

loss caused by delays in production.

BOARD NOTE: Derived from 40 CFR 403

•

17(a), as added at

53 Fed. Reg. 40615, October 17, 1988.

(Source: Amended at

_________

effective

)

Ill. Reg.

_________

---

112

Section 310.911

Bypass Not Violating Applicable Pretreatment

Standards or Requirements

An industrial user may allow any bypass to occur which does not

cause pretreatment standards or requirements to be violated, but

only if it also is for essential maintenance to assure efficient

operation. These bypasses are not subject to the provisions of

Sections 310.912 and 310.913.

BOARD NOTE: Derived from 40 CFR 403.17(b), as added at 53 Fed.

Peg. 40615, October 17, 1988.

(Source: Amended at

______

Ill. Reg.

effective

_______________________________________________ )

Section 310.912

Notice

a) If an industrial user knows in advance of the need for

a bypass, it shall submit prior notice to the control

authority, if possible at least 10 days before the date

of the bypass.

b) An industrial user shall submit oral notice of an

unanticipated bypass that exceeds applicable

pretreatment standards to the control authority within

24 hours from the time the industrial user becomes

aware of the bypass. A written submission shall also

be provided within 5 days of the time the industrial

user becomes aware of the bypass. The written

submission must contain:

1) A description of the bypass and its cause,

2) The duration of the bypass, including exact dates

and times and,

3) If the bypass has not been corrected, the

anticipated time it is expected to continue and

the steps taken or planned to reduce, eliminate

and prevent reoccurrence of the bypass.

c) The control authority may waive the written report on a

case—by—case basis if the oral report has been received

within 24 hours.

BOARD NOTE: Derived from 40 CFR 403.17(c), as added at

53 Fed. Peg. 40615, October 17, 1988.

(Source: Amended at

______

Ill. Reg.

________,

effective

)

---

113

Section 310.913

Prohibition of Bypass

a) Bypass is prohibited unless:

1) Bypass was unavoidable to prevent loss of life,

personal injury or severe property damage;

2) There were no feasible alternatives to the bypass,

such as the use of auxiliary treatment facilities,

retention of untreated wastes or maintenance

during normal periods of equipment downtime. This

condition is not satisfied if adequate back-up

equipment should have been installed in the

exercise of reasonable engineering judgment to

prevent a bypass which occurred during normal

periods of equipment downtime or preventative

maintenance; and

3) The industrial user submitted notices as required

under Section 310.912.

b) The control authority may approve an anticipated

bypass, after considering its adverse effects, if the

control authority determines that the bypass will meet

the requirements of subsection (a).

BOARD NOTE: Derived from 40 CFR 403.17(d), as added at

53 Fed. Peg. 40615, October 17, 1988.

(Source: Amended at

Ill. Peg.

________,

effective

_______________________________________________

)

IT IS SO ORDERED.

I, Dorothy N. Gunn, Clerk of the Illinois Pollution Control

Board, hereby certify,that the above opipion and order was

adopted on the

~

day of

~

1995, by a vote of

________

~&~~42~.

~

Dorothy M7/Gunn, Clerk

Illinois ~bllution Control Board