1. TITLE 35: ENVIRONMENTAL PROTECTION
  2. SUBTITLE B: AIR POLLUTION
    1. CHAPTER I: POLLUTION CONTROL BOARD
    2. SUBCHAPTER K: EMISSION STANDARDS AND LIMITATIONS FOR MOBILE SOURCES
      1. PART 240
      2. MOBILE SOURCES
        1. Section 240.192 On-Board Diagnostic Test Standards

TITLE 35: ENVIRONMENTAL PROTECTION

Back to top

SUBTITLE B: AIR POLLUTION


CHAPTER I: POLLUTION CONTROL BOARD


SUBCHAPTER K: EMISSION STANDARDS AND LIMITATIONS FOR MOBILE SOURCES

 


PART 240

 


MOBILE SOURCES

 

SUBPART A: DEFINITIONS AND GENERAL PROVISIONS

 

Section

240.101

Preamble

240.102

Definitions

240.103

Prohibitions

240.104

Inspection

240.105

Penalties

240.106

Determination of Violation

240.107

Incorporations by Reference

 

SUBPART B: EMISSIONS

 

Section

240.121

Smoke Emissions

240.122

Diesel Engine Emissions Standards for Locomotives

240.123

Liquid Petroleum Gas Fuel Systems

240.124

Vehicle Exhaust Emission Standards (repealed)

240.125

Compliance Determination (repealed)

 

SUBPART C: SMOKE OPACITY STANDARDS AND TEST PROCEDURES FOR DIESEL-POWERED HEAVY DUTY VEHICLES

 

Section

240.140

Applicability

240.141

Smoke Opacity Standards and Test Procedures for Diesel-Powered Heavy Duty Vehicles

 

SUBPART D: STEADY-STATE IDLE MODE TEST EMISSION STANDARDS

 

Section

240.151

Applicability

240.152

Steady-State Idle Mode Vehicle Exhaust Emission Standards

240.153

Compliance Determination

 

SUBPART E: TRANSIENT LOADED MODE TEST EMISSION STANDARDS

 

Section

240.161

Applicability

240.162

Vehicle Exhaust Emission Start-Up Standards

240.163

Vehicle Exhaust Emission Final Standards

240.164

240.165

Vehicle Exhaust Emission Fast-Pass Standards

Compliance Determination

 

SUBPART F: EVAPORATIVE TEST STANDARDS

 

Section

240.171

Applicability

240.172

Evaporative System Integrity Test Standards

240.173

Evaporative System Purge Test Standards (Repealed)

 

SUBPART G: ON-ROAD REMOTE SENSING TEST EMISSION STANDARDS

 

Section

240.181  Applicability

240.182  On-Road Remote Sensing Emission Standards

      
    1. Compliance Determination
    SUBPART H: ON-BOARD DIAGNOSTIC TEST STANDARDS
    Section
    240.191
    Applicability
    240.192
    On-Board Diagnostic Test Standards
    240.193
    Compliance Determination

    240.Appendix A

    Rule into Section Table

    240.Appendix B

    Section into Rule Table

       

    240.Table A

    Vehicle Exhaust Emission Start-Up Standards

    240.Table B

    Vehicle Exhaust Emission Final Standards

    240.Table C Vehicle Exhaust Emission Fast-Pass Standards

     

    AUTHORITY: Implementing Sections 9, 10 and 13 and authorized by Sections 27 and 28.5 of the Environmental Protection Act [415 ILCS 5/9, 10, 13, 27, and 28.5] and Section 13B-20 of the Vehicle Emissions Inspection Law of 1995 [625 ILCS 5/13B-20]; implementing Section 13-109.2 of the Illinois Vehicle Code [625 ILCS 5/13-109.2].

     

    SOURCE: Adopted as Chapter 2: Air Pollution, Part VII: Mobile Sources, filed and effective April 14, 1972; codified at 7 Ill. Reg. 13628; amended in R85-25, at 10 Ill. Reg. 11277, effective June 16, 1986; amended in R90-20 at 16 Ill. Reg. 6184, effective April 7, 1992; amended in R94-20 at 18 Ill. Reg. 18013, effective December 12, 1994; amended in R94-19 at 18 Ill. Reg. 18228, effective December 20, 1994; amended in R98-24 at 22 Ill. Reg. 13723, effective July 13, 1998; expedited correction at 22 Ill. Reg. 21120, effective July 13, 1998; amended in R01-12 at 24 Ill. Reg. 19188, effective December 18, 2000; amended in R01-8 at 25 Ill. Reg. 3680, effective February 26, 2001; amended in R02-8 at 25 Ill. Reg. _____, effective __________.

     

    BOARD NOTE: This part implements the Environmental Protection Act as of July 1, 1994.

     

    NOTE: Capitalization denotes statutory language.

     

     

    SUBPART H: ON-BOARD DIAGNOSTIC TEST STANDARDS

     
    Section 240.191 Applicability
     

    The standards of this Subpart apply to all 1996 and newer model year light duty vehicles, light duty trucks 1, and light duty trucks 2 that are required to meet the standards contained in 40 CFR § 86.094-17 and which are inspected utilizing the on-board diagnostic test procedures contained in 35 Ill. Adm. Code 276.209. Vehicles that receive a result of fail do not thereby fail their emissions test until January 1, 2002. However, this date shall be extended to January 1, 2003, if the Agency petitions the USEPA for such an extension, and the request for an extension is approved by the USEPA pursuant to 40 CFR § 51.357(a)(12).

     

    (Source: Amended at 25 Ill. Reg. , effective                        p )

     
     


    Section 240.192 On-Board Diagnostic Test Standards

     

    Vehicles subject to on-board diagnostic testing shall fail the on-board diagnostic test if one of the following occurs:

     

      1. the vehicle connector is missing, has been tampered with, or is otherwise inoperable; or
          1. the malfunction indicator light is commanded to be illuminated and it is not visually illuminated according to visual inspection; or
          1. the malfunction indicator light is commanded to be illuminated for and any of the following on-board diagnostic trouble codes are present (where x refers to any digit):; or
          1. Any PX1XX Fuel and Air Metering codes
        1. Any PX2XX Fuel and Air Metering codes
        2. Any PX3XX Ignition System or Misfire codes
        3. Any PX4XX Auxiliary Emission Controls codes
        4. P0500 Vehicle Speed Sensor Malfunction
        5. P0501 Vehicle Speed Sensor Range/Malfunction
        6. P0502 Vehicle Speed Sensor Circuit Low Input
        7. P0503 Vehicle Speed Sensor Intermittent/Erratic/High
        8. P0505 Idle Control System Malfunction
        9. P0506 Idle Control System RPM Lower Than Expected
        10. P0507 Idle Control System RPM Higher Than Expected
        11. P0510 Closed Throttle Position Switch Malfunction
        12. P0550 Power Steering Pressure Sensor Circuit Malfunction
        13. P0551 Power Steering Pressure Sensor Circuit Malfunction
        14. P0552 Power Steering Pressure Sensor Circuit Low Input
        15. P0553 Power Steering Pressure Sensor Circuit Intermittent
        16. P0554 Power Steering Pressure Sensor Circuit Intermittent
        17. P0560 System Voltage Malfunction
        18. P0561 System Voltage Unstable
        19. P0562 System Voltage Low
        20. P0563 System Voltage High
        21. Any PX6XX Computer and Output Circuits Codes
        22. P0703 Brake Switch Input
        23. P0705 Transmission Range Sensor Circuit Malfunction (PRNDL Input)
        24. P0706 Transmission Range Sensor Circuit Range/Performance
        25. P0707 Transmission Range Sensor Circuit Low Input
        26. P0708 Transmission Range Sensor Circuit High Input
        27. P0709 Transmission Range Sensor Circuit Intermittent
        28. P0719 Torque Converter/Brake Switch “B” Circuit Low
        29. P0720 Output Speed Sensor Circuit Malfunction
        30. P0721 Output Speed Sensor Circuit Range/Performance
        31. P0722 Output Speed Sensor Circuit No Signal
        32. P0723 Output Speed Sensor Circuit Intermittent
        33. P0724 Torque Converter/Brake Switch “B” Circuit High
        34. P0725 Engine Speed Input Circuit Malfunction
        35. P0726 Engine Speed Input Circuit Range/Performance
        36. P0727 Engine Speed Input Circuit No Signal
        37. P0728 Engine Speed Input Circuit Intermittent
        38. P0740 Torque Converter Clutch System Malfunction
        39. P0741 Torque Converter System Performance or Stuck Off
        40. P0742 Torque Converter System Stuck On
        41. P0743 Torque Converter System Electrical
        42. P0744 Torque Converter System Intermittent
          43. d)
          the malfunction indicator light (MIL) does not illuminate at all when the vehicle is in the key-on/engine-off condition.
           

          (Source: Amended at 25 Ill. Reg. , effective            p )

           
          Section 240.193 Compliance Determination
            
          Compliance shall be determined based upon the inspection of the on-board diagnostic vehicle connector, malfunction indicator light, and electronic retrieval of data stored in the vehicle’s on-board diagnostic system fault codes using the on-board diagnostic test procedures that will be adopted by the Agency in 35 Ill. Adm. Code 276.
           
          (Source: Amended at 25 Ill. Reg. , effective                       p )

          Back to top